- Critical: Eating, Drinking, or Using Tobacco* (corrected on site) (repeated violation)
Observation: In use open drinking containers stored in a manner that may contaminate food, food contact surfaces or utensils.
Correction: Employees may drink from a closed beverage container if the container is handled to prevent contamination of (1) The employee's hands (2) The container and (3) Exposed food clean equipment, utensils, and linens and unwrapped single-service and single-use articles.
- Utensils - In-Use - Between-Use Storage
Observation: Dispensing utensils improperly stored between uses.
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Cloths - Wiping Cloths - Use Limitation
Observation: Wiping cloths improperly stored between use.
Correction: Ensure wet wiping cloths are stored in a chemical sanitizer at the proper concentration between use.
- Sanitizing Solutions, Testing Devices (repeated violation)
Observation: There is no properly working test kit provided in the facility for monitoring the concentration of the chemical sanitizing solutions.
Correction: Obtain a quaternary ammonia test kit so that employees can accurately monitor the concentration of the sanitizing solutions and maintain them at a safe and effective level.
- Equipment - Good Repair and Proper Adjustment
Observation: The door gasket to the end refrigerator on the cook line is in poor repair.
Correction: Repair or replace the door gasket in accordance with the manufacturer's specifications.
- Equipment - Good Repair and Proper Adjustment
Observation: Mechanically vented hood filters not in good repair or have gaps in between filters.
Correction: Repair or replace hood filters and/or eliminate gaps between filters.
- Warewashing - Mechanical Warewashing Equipment, Hot Water Sanitization Temperatures (repeated violation)
Observation: The water temperature in the manifold servicing the high temperature ware wash machine was below the minimum allowable level of 180ºF. The thermometer read <180ºF>. but the dishes were not hot and the heat sensitive label did not turn.
Correction: Immediately discontinue the use of the machine until it is operating in accordance with minimum requirements. Initiate manual wash, rinse, and sanitize method to properly clean and sanitize equipment and utensils.
- Handwashing - Using a Handwashing Lavatory (corrected on site)
Observation: The handwashing facility located at the dish area is blocked, preventing access by employees for easy handwashing.
Correction: Access to the handwashing facility identified above is to be available during all hours of operation. Remove the @EQUIPMENT@ preventing its use.
- Handwashing Cleanser - Availability
Observation: Soap was not provided at the hand washing lavatory in the bar area
Correction: Hand soap must be provided at all hand washing lavatories to encourage proper hand washing. Hand cleanser must always be present to aid in reducing microorganisms and particulate matter found on hands.
- Hand Drying Provision (repeated violation)
Observation: No disposable towels were provided at the hand washing lavatory in the server area
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
- Pests - Controlling Pests* (repeated violation)
Observation: There are roaches in the kitchen and dining area
Correction: Inspect premises on routine basis for the evidence of pests. . Insects and other pests are capable of transmitting disease to man by contaminating food and food-contact surfaces.
- Critical: Toxics - Common Name/working Containers of Toxics*
Observation: Working containers of cleaning chemicals are not properly labeled.
Correction: Working containers of toxic items are to be properly labeled with contents. Identification of these containers with the common name of the material helps prevent the dangerous misuse of the contents.
|
12/14/2015 | Routine | |
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site) (repeated violation)
Observation: Sauce on ice, under salad prep unit, end prep unit,#6 cold holding at improper temperatures
Correction: Relocate food to a refrigeration unit that is capable of maintaining food storage at 41°F or below.
- Temperature Measuring Devices - Ambient Air and Water (repeated violation)
Observation: The ambient (air/water) temperature measuring device (degrees F) located in the dish machine is not accurate.
Correction: Provide a temperature measuring device that is accurate within +/- 3 degrees Fahrenheit in the intended range of use.
- Sanitizing Solutions, Testing Devices (repeated violation)
Observation: There is no properly working test kit provided in the facility for monitoring the concentration of the chemical sanitizing solutions.
Correction: Obtain a quaternary ammonia test kit so that employees can accurately monitor the concentration of the sanitizing solutions and maintain them at a safe and effective level.
- Warewashing - Mechanical Warewashing Equipment, Hot Water Sanitization Temperatures (repeated violation)
Observation: The water temperature in the manifold servicing the high temperature ware wash machine was below the minimum allowable level of 180ºF. The thermometer read 130ºF>.
Correction: Immediately discontinue the use of the machine until it is operating in accordance with minimum requirements. Initiate manual wash, rinse, and sanitize method to properly clean and sanitize equipment and utensils.
- Handwashing - Using a Handwashing Lavatory (corrected on site)
Observation: The handwashing facility located at the end of the kitchen is blocked, preventing access by employees for easy handwashing.
Correction: Access to the handwashing facility identified above is to be available during all hours of operation. Remove the floor mats preventing its use.
- Hand Drying Provision (repeated violation)
Observation: No disposable towels were provided at the hand washing lavatory in the server area and bar.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
- Pests - Controlling Pests*
Observation: There are roaches in the kitchen and dining area
Correction: Eliminate harborage conditions. Insects and other pests are capable of transmitting disease to man by contaminating food and food-contact surfaces.
|
06/15/2015 | Routine | |
- Critical: Eating, Drinking, or Using Tobacco* (corrected on site)
Observation: In use open drinking containers stored in a manner that may contaminate food, food contact surfaces or utensils.
Correction: Employees may drink from a closed beverage container if the container is handled to prevent contamination of (1) The employee's hands (2) The container and (3) Exposed food clean equipment, utensils, and linens and unwrapped single-service and single-use articles.
- Critical: Hands - Preventing Contamination from Hands* (corrected on site)
Observation: Employees observed handling ready-to-eat (RTE) food with their bare hands.
Correction: Provide suitable utensils such as deli tissue, spatulas, tongs, single-use gloves, or dispensing equipment to handle RTE food to prevent contamination from hands.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site)
Observation: FOOD being held on ice and in the jerk box cold holding at improper temperatures
Correction: Relocate food to a refrigeration unit that is capable of maintaining food storage at 41°F or below.
- Nonfood-Contact Surfaces - Corrosion Resistant/Nonabsorbent
Observation: The nonfood contact surface of the bare wood shelves at the soft drink area is not corrosion resistant, nonabsorbent, and/or smooth.
Correction: Nonfood contact equipment that is exposed to splash, spillage, food soiling, or requires frequent cleaning must be smooth, durable, and nonabsorbent.
- Temperature Measuring Devices - Ambient Air and Water
Observation: The ambient (air/water) temperature measuring device (dual or degrees Fl) located in the dish machine is not working
Correction: Provide a temperature measuring device that is easily readable and accurate to +/-3 degrees Fahrenheit in the intended range of use.
- Sanitizing Solutions, Testing Devices (repeated violation)
Observation: There is no properly working test kit provided in the facility for monitoring the concentration of the chemical sanitizing solutions.
Correction: Obtain a quaternary ammonia test kit so that employees can accurately monitor the concentration of the sanitizing solutions and maintain them at a safe and effective level.
- Plumbing System Maintained in Good Repair
Observation: Plumbing connections under the server hand sink are leaking.
Correction: Plumbing systems and components shall be maintained in good repair.
- Hand Drying Provision (repeated violation)
Observation: No continuous towel system that supplies the user with a clean towel has been provided on the back line near the dish machine..
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
- Critical: Pests-Controlling Pests*
Observation: There are roaches in the kitchen and bar areas
Correction: The presence of insects, rodents, and other pests shall be controlled to minimize their presence on the premises by using methods such as trapping devices or other methods as required.
|
02/05/2015 | Routine | |
- Warewashing - Mechanical Warewashing Equipment, Hot Water Sanitization Temperatures (corrected on site) (repeated violation)
Observation: The water temperature in the manifold servicing the high temperature ware wash machine was below the minimum allowable level of 180ºF. The thermometer read <190ºF>, but the temperature sensitive label did not indicate that the dishes were hot enought to be sanitized. Test this machine daily to ensure that it is sanitizing dishes properly as it has been out of compliance on most inspections.
Correction: Machine repaired during inspection. Immediately discontinue the use of the machine until it is operating in accordance with minimum requirements. Initiate manual wash, rinse, and sanitize method to properly clean and sanitize equipment and utensils.
- Hand Drying Provision
Observation: No continuous towel system that supplies the user with a clean towel has been provided at the hand sink near the dish machine on the back wall.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
- Hand Drying Provision (repeated violation)
Observation: No disposable towels were provided at the hand washing lavatory in the back of the kitchen and server area in the dining room.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
- Critical: Toxics - Storage of Toxic Containers* (corrected on site)
Observation: Containers of cleaning chemicals are not properly stored to prevent the contamination of food, equipment, utensils, linens or single service items.
Correction: Containers of cleaning chemicals must be located in an area that is not above food, equipment, utensils, linens or single service items.
|
08/04/2014 | Routine | |
Facility must provide test strips for all dish machines including the hot water sanitizing machines and test them daily.
- Critical: Food - Consumption of Raw or Undercooked Animal Foods
Observation: Raw and/or undercooked ahi tuna and ground beef is/are provided on the menu, menu board, table tent or brochure without proper disclosure.
Correction: The Consumer Advisory shall include a disclosure statement that includes a description of the animal-derived foods and identification of the animal-derived foods by asterisking (*) them to a footnote that states that the items are served raw or undercooked, or contain raw or undercooked ingredients.
- Sanitizing Solutions, Testing Devices
Observation: There is no properly working test kit provided in the facility for monitoring the concentration of the chemical sanitizing solutions.
Correction: Obtain both a chlorine and quaternary ammonia test kit so that employees can accurately monitor the concentration of the sanitizing solutions and maintain them at a safe and effective level.
- Warewashing - Mechanical Warewashing Equipment, Hot Water Sanitization Temperatures (corrected on site) (repeated violation)
Observation: The water temperature in the manifold servicing the high temperature ware wash machine was below the minimum allowable level of 180ºF. The thermometer read <195ºF> but the temperature sensitive tape did not indicate the water had reached the proper temperature..
Correction: Immediately discontinue the use of the machine until it is operating in accordance with minimum requirements. Initiate manual wash, rinse, and sanitize method to properly clean and sanitize equipment and utensils.
- Critical: Equipment and Utensils - Hot Water and Chemical Sanitizing* (corrected on site) (repeated violation)
Observation: Due to improper operation of the low temperature chemical sanitizing mechanical warewashing machine at the bar, equipment food-contact surfaces and utensils are not sanitized after cleaning. (See 12 VAC 5-421-1700)
Correction: Repair the unit to restore chemical sanitization. Verify the level of sanitizer and continually monitor by the use of test strips/kit.
- Handwashing Cleanser - Availability
Observation: Soap was not provided at the hand washing lavatory in the bar and server area.
Correction: Hand soap must be provided at all hand washing lavatories to encourage proper hand washing. Hand cleanser must always be present to aid in reducing microorganisms and particulate matter found on hands.
- Hand Drying Provision (repeated violation)
Observation: No disposable towels were provided at the hand washing lavatory in the server area
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
|
03/20/2014 | Routine | |
- Cloths - Wiping Cloths - Use Limitation
Observation: Wiping cloths improperly stored between use.
Correction: Ensure wet wiping cloths are stored in a chemical sanitizer at the proper concentration between use.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site)
Observation: FOOD in prep unit #2 cold holding at improper temperatures
Correction: Relocate food to a refrigeration unit that is capable of maintaining food storage at 41°F or below.
- Hand Drying Provision
Observation: No disposable towels were provided at the hand washing lavatory in the wait station
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
|
09/27/2013 | Routine | |
Test hot water dish machine daily
- Critical: Eating, Drinking, or Using Tobacco*
Observation: In use open drinking containers stored in a manner that may contaminate food, food contact surfaces or utensils.
Correction: Employees may drink from a closed beverage container if the container is handled to prevent contamination of (1) The employee's hands (2) The container and (3) Exposed food clean equipment, utensils, and linens and unwrapped single-service and single-use articles.
- Warewashing - Mechanical Warewashing Equipment, Hot Water Sanitization Temperatures (corrected on site) (repeated violation)
Observation: The water temperature in the manifold servicing the high temperature ware wash machine was below the minimum allowable level of 150º - 160 F in the wash cycle and read 194 degrees F in the rinse cycle. However it did not turn the temperature sensitive tape.
Correction: Immediately discontinue the use of the machine until it is operating in accordance with minimum requirements. Initiate manual wash, rinse, and sanitize method to properly clean and sanitize equipment and utensils.
- Critical: Equipment and Utensils - Hot Water and Chemical Sanitizing* (corrected on site)
Observation: Due to improper operation of the low temperature chemical sanitizing mechanical warewashing machine, equipment food-contact surfaces and utensils are not sanitized after cleaning in the bar area. (See 12 VAC 5-421-1700)
Correction: Repair the unit to restore chemical sanitization. Verify the level of sanitizer and continually monitor by the use of test strips/kit.
- Handwashing Cleanser - Availability
Observation: Soap was not provided at the hand washing lavatory in the left end of the line.
Correction: Hand soap must be provided at all hand washing lavatories to encourage proper hand washing. Hand cleanser must always be present to aid in reducing microorganisms and particulate matter found on hands.
|
03/29/2013 | Routine | |
- Critical: Equipment and Utensils - Hot Water and Chemical Sanitizing* (corrected on site)
Observation: Due to improper operation of the low temperature chemical sanitizing mechanical warewashing machine, equipment food-contact surfaces and utensils are not sanitized after cleaning. (See 12 VAC 5-421-1700)
Correction: Repair the unit to restore chemical sanitization. Verify the level of sanitizer and continually monitor by the use of test strips/kit.
- Hand Drying Provision (corrected on site)
Observation: No disposable towels were provided at the hand washing lavatory in the bar area
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
|
09/28/2011 | Risk Factor Assessment | |
Restaurant representatives - add corrected or new information about Shula's 347 Grill, 2801 Hershberger Road Nw, Roanoke, VA 24017 »