- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Raw food of animal origin holding in a manner that may cause cross contamination of to ready-to-eat food (RTE).
Correction: Separate raw foods during storage, preparation, holding, and display from raw RTE food including other raw food such as fish for sushi or molluscan shellfish, or other raw RTE food such as vegetables, and cooked RTE food.
- Food Storage - Clean and Dry Location (corrected on site)
Observation: Food stored on the floor or food stored less than 6" above the floor: walk-in and dry storage.;Elevate food storage onto approved shelving with minimum 6" legs or casters.
- Temperature Measuring Devices (repeated violation)
Observation: There was no temperature measuring device located in the refrigeration units.
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Handwashing - Using a Handwashing Lavatory - No Other Purpose
Observation: The handwash station at the is being used to clean equipment and utensils.
Correction: The handwash facility identified above is to be used for washing hands only
- Outer Openings - Protected (repeated violation)
Observation: Outer opening of the food establishment is not protected against entry of insects and rodents: hole in screen door.
Correction: Protect the food establishment against the entry of insects and rodents by 1. Filling or closing holes and other gaps along floors, walls, and ceilings, 2. Closed, tight fitting windows, and 3. Solid, self-closing, tight-fitting doors. Insects and rodents are vectors of disease-causing microorganisms which may be transmitted to humans by contamination of food and food-contact surfaces.
- Handwashing Cleanser - Availability
Observation: Soap was not provided at the hand washing lavatory
Correction: Hand soap must be provided at all hand washing lavatories to encourage proper hand washing. Hand cleanser must always be present to aid in reducing microorganisms and particulate matter found on hands.
- Hand Drying Provision
Observation: No disposable towels were provided at the hand washing lavatory
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
|
03/23/2016 | Routine | |
All critical violations were discussed and corrected during inspection.
- Critical: Hands - Preventing Contamination from Hands* (corrected on site)
Observation: Employees observed handling ready-to-eat (RTE) food with their bare hands.
Correction: Provide suitable utensils such as deli tissue, spatulas, tongs, single-use gloves, or dispensing equipment to handle RTE food to prevent contamination from hands.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Different types of raw animal foods stored in such a manner that may cause cross contamination.
Correction: Separate types of raw animal foods from each other such as beef, fish, lamb pork, and poultry during storage, preparation, holding, and display by the following: (a) Using separate equipment for each type. (b) Arranging each type of food in equipment so that cross contamination of one type with another is prevented. (c) Preparing each type of food at different times or in separate areas.
- Food Storage Containers - Identified with Common Name of Food
Observation: Unlabeled food containers.
Correction: Label working containers with the common name of its contents. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient when the consumer has requested that it not be used may result in severe medical consequences. Liquid foods and granular foods may resemble cleaning compounds. The mistaken use of food from an unlabeled container could result in chemical poisoning.
- Thawing
Observation: Improper methods used to thaw chicken.
Correction: Thaw potentially hazardous foods by either of the following methods: 1. Under refrigeration that maintains food temperature at 41°F (45°F) 2. Completely submerged under running water at a temperature of 70°F or below with sufficient water velocity to agitate and float off loose particles in an overflow. Ready-to-eat food shall not exceed 41°F and raw animal foods shall not exceed 41°F for more than four hours 3. As part of the cooking process
- Cooling Methods
Observation: The methods used for cooling were not adequate.
Correction: Cool foods by the following methods: 1. Placing food in shallow pans 2. Separating food into smaller thinner portions 3. Using rapid chill cooling equipment 4. Stirring the food in a container placed in an ice water bath 5. Using containers that facilitate heat transfer 6. Adding ice as an ingredient 7. Any other method that can effectively accomplish cooling.
- Critical: Time as a Public Health Control* (corrected on site) (repeated violation)
Observation: Garlic and oil and fried chicken for which time rather than temperature is being used as a control was not labeled or otherwise marked with a 4 hour cook, serve or discard by time.
Correction: Discard food that is not cooked and served or served if ready-to-eat within 4 hours from the point in time when the food is removed from temperature control. Clearly label or otherwise mark the food with a 4-hour cook-serve or serve by time.
- Temperature Measuring Devices (repeated violation)
Observation: There was no temperature measuring device located in multiple refrigeration units.
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Equipment, Utensils, Linens, and Single-Service and Single-Use Articles
Observation: Single service items observed unprotected from contamination.
Correction: Store single service items in its original protective packaging or inverted in an approved dispenser.
- Handwashing - Using a Handwashing Lavatory
Observation: The handwashing facility located at the kitchen is blocked, preventing access by employees for easy handwashing.
Correction: Access to the handwashing facility identified above is to be available during all hours of operation. Remove the @EQUIPMENT@ preventing its use.
- Outer Openings - Protected
Observation: Outer opening of the food establishment is not protected against entry of insects and rodents.
Correction: Protect the food establishment against the entry of insects and rodents by 1. Filling or closing holes and other gaps along floors, walls, and ceilings, 2. Closed, tight fitting windows, and 3. Solid, self-closing, tight-fitting doors. Insects and rodents are vectors of disease-causing microorganisms which may be transmitted to humans by contamination of food and food-contact surfaces.
- Lighting, Intensity
Observation: Less than 10 foot candles of light was noted in the dry storage area.
Correction: Provide at least 10 foot candles at a distance of 30 inches from the floor in the walk-in refrigeration units and dry storage areas and in other areas and rooms during periods of cleaning.
- Dressing Rooms - Using Dressing Rooms and Lockers
Observation: Employees are not using the dressing rooms, designated area or lockers provided.
Correction: Employees that regularly change their clothes in the establishment should use the dressing room or lockers provided.
|
11/18/2015 | Routine | |
Critical violations discussed and corrected during inspection. Chinese employee illness reporting form left with PIC.
- Critical: Hands - When to Wash* (corrected on site)
Observation: A food employee failed to wash his or her hands before engaging in food preparation, after touching bare human body parts, after coughing, sneezing, eating, after handling soiled utensils or after engaging in any activity which may have contaminated his/her hands.
Correction: Instruct food employees to clean their hands and exposed portions of their arms immediately before engaging in food preparation including working with exposed food, clean equipment and utensils, and unwrapped single-service and single-use articles and during food preparation, as often as necessary to remove soil and contamination and to prevent cross contamination when changing task.
- Critical: Eating, Drinking, or Using Tobacco* (corrected on site)
Observation: The employee is drinking from an unapproved container in the food preparation area.
Correction: Employees may drink from a closed beverage container if the container is handled to prevent contamination of (1) The employee's hands, (2) The container, and (3) Exposed food, clean equipment, utensils, and linens, and unwrapped single-service and single-use articles.
- Critical: Package Integrity* (corrected on site) (repeated violation)
Observation: Food packages are not in good condition or the integrity of the package contents are not protected from adulteration or potential contaminants (ex: dented food cans)
Correction: Discard or return to distributor any food packages that are not in good condition or the integrity of the package contents are not protected from adulteration or potential contaminants.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Raw food of animal origin holding in a manner that may cause cross contamination of to ready-to-eat food (RTE).
Correction: Separate raw foods during storage, preparation, holding, and display from raw RTE food including other raw food such as fish for sushi or molluscan shellfish, or other raw RTE food such as vegetables, and cooked RTE food.
- Food Storage - Clean and Dry Location
Observation: Food stored in a location where it is subject to splash, dust or other contamination. Uncovered food in storage.
Correction: Store food where it is not exposed to splash or install an approved durable, and cleanable barrier between the splash source and the food to prevent contamination.
- Food Storage - Clean and Dry Location (repeated violation)
Observation: Food stored on the floor or food stored less than 6" above the floor.;Elevate food storage onto approved shelving with minimum 6" legs or casters.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site)
Observation: The prepared ready-to-eat (RTE) food in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Critical: Time as a Public Health Control* (corrected on site)
Observation: No written procedures for the use of time as a public health control with potentially hazardous foods.
Correction: Provide written procedures for the use of time as a public health control. The procedures must include the following steps or practices: a. Food must be marked with the time within which it must be cooked, served or discarded. b. The food is served or discarded within four hours from the time when the food is removed from temperature control c. Food in unmarked containers or packages, or for which the time expires is discarded and d. Written procedures are maintained in the food establishment and made available to the regulatory authority upon request e. Once time is implemented as a control measure for potentially hazardous food, no other measures may be substituted.
- Critical: Time as a Public Health Control* (corrected on site)
Observation: Garlic and oil,chicken, and egg rolls for which time rather than temperature is being used as a control was not labeled or otherwise marked with a 4 hour cook, serve or discard by time.
Correction: Discard food that is not cooked and served or served if ready-to-eat within 4 hours from the point in time when the food is removed from temperature control. Clearly label or otherwise mark the food with a 4-hour cook-serve or serve by time.
- Temperature Measuring Devices (corrected on site)
Observation: There was no temperature measuring device located in the low boy refrigerator.
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Hand Drying Provision (corrected on site) (repeated violation)
Observation: No disposable towels were provided at the hand washing lavatory in the kitchen.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
|
07/06/2015 | Routine | |
- Nonfood-Contact Surfaces - Corrosion Resistant/Nonabsorbent
Observation: The nonfood contact surface of the cardboard lining shelves is not corrosion resistant, nonabsorbent, and/or smooth.
Correction: Nonfood contact equipment that is exposed to splash, spillage, food soiling, or requires frequent cleaning must be smooth, durable, and nonabsorbent.
- Hand Drying Provision (corrected on site) (repeated violation)
Observation: No disposable towels were provided at the hand washing lavatory in the kitchen.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
|
05/06/2015 | Routine | |
All violations were discussed and corrected during inspection.
- Critical: Package Integrity* (corrected on site)
Observation: Food packages are not in good condition or the integrity of the package contents are not protected from adulteration or potential contaminants (ex: dented food cans)
Correction: Discard or return to distributor any food packages that are not in good condition or the integrity of the package contents are not protected from adulteration or potential contaminants.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site)
Observation: Raw foods of animal origin stored over ready-to-eat (RTE) food in the refrigeration unit.
Correction: Separate raw foods of animal origin during storage, preparation, holding, and display from raw RTE food including foods such as fish for sushi or molluscan shellfish, or other raw RTE food such as vegetables, and cooked RTE food.
- Food Storage Containers - Identified with Common Name of Food
Observation: Unlabeled food containers.
Correction: Label working containers with the common name of its contents. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient when the consumer has requested that it not be used may result in severe medical consequences. Liquid foods and granular foods may resemble cleaning compounds. The mistaken use of food from an unlabeled container could result in chemical poisoning.
- Food Storage - Clean and Dry Location
Observation: Food stored in a location where it is subject to splash, dust or other contamination.
Correction: Store food where it is not exposed to splash or install an approved durable, and cleanable barrier between the splash source and the food to prevent contamination.
- Food Storage - Clean and Dry Location
Observation: Food stored on the floor or food stored less than 6" above the floor.;Elevate food storage onto approved shelving with minimum 6" legs or casters.
- Nonfood-Contact Surfaces - Corrosion Resistant/Nonabsorbent
Observation: The nonfood contact surface of the egg carton trays are not corrosion resistant, nonabsorbent, and/or smooth.
Correction: Nonfood contact equipment that is exposed to splash, spillage, food soiling, or requires frequent cleaning must be smooth, durable, and nonabsorbent.
- Handwashing - Using a Handwashing Lavatory
Observation: The handwashing facility located at the hand sink is blocked, preventing access by employees for easy handwashing.
Correction: Access to the handwashing facility identified above is to be available during all hours of operation. Remove the @EQUIPMENT@ preventing its use.
- Refuse - Outside Storage Prohibitions
Observation: Discarded products with food residue are being stored outside of refuse containers, outside of the establishment.
Correction: Provide enough pest and rodent proof refuse containers for the storage of all waste with food residue.
- Handwashing Cleanser - Availability
Observation: Soap was not provided at the hand washing lavatory in the hand sink.
Correction: Hand soap must be provided at all hand washing lavatories to encourage proper hand washing. Hand cleanser must always be present to aid in reducing microorganisms and particulate matter found on hands.
- Hand Drying Provision
Observation: No disposable towels were provided at the hand washing lavatory in the hand sink.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
- Critical: Toxics - Common Name/working Containers of Toxics* (corrected on site) (repeated violation)
Observation: Working containers of chlorine/bleach are not properly labeled.
Correction: Working containers of toxic items are to be properly labeled with contents. Identification of these containers with the common name of the material helps prevent the dangerous misuse of the contents.
|
02/11/2015 | Routine | |
- Utensils - In-Use - Between-Use Storage
Observation: Scoop with no handle is used to scoop rice and is stored in product.
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site) (repeated violation)
Observation: The prepared ready-to-eat (RTE) food such as chicken in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Critical: Toxics - Common Name/working Containers of Toxics* (corrected on site)
Observation: Working container of floor cleaner is not properly labeled.
Correction: Working containers of toxic items are to be properly labeled with contents. Identification of these containers with the common name of the material helps prevent the dangerous misuse of the contents.
|
11/12/2014 | Routine | |
- Critical: Cooling* (corrected on site) (repeated violation)
Observation: Chicken noted not being adequately cooled to prevent the growth of harmful bacteria.
Correction: Cool potentially hazardous foods from 135°F to 70°F within 2 hours and within a total of 6 hours from 135°F to 41°F. A longer time for cooling allows an ideal situation for bacterial growth. This has been shown to be the major contributing factor in many foodborne illnesses.
- Cooling Methods (corrected on site) (repeated violation)
Observation: The methods used for cooling were not adequate.
Correction: Cool foods by the following methods: 1. Placing food in shallow pans 2. Separating food into smaller thinner portions 3. Using rapid chill cooling equipment 4. Stirring the food in a container placed in an ice water bath 5. Using containers that facilitate heat transfer 6. Adding ice as an ingredient 7. Any other method that can effectively accomplish cooling.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site) (repeated violation)
Observation: Chicken, chicken breading, and pooled shell eggs are cold holding at improper temperatures.
Correction: Cold hold potentially hazardous food at 41°F or below to inhibit the growth of harmful bacteria.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site)
Observation: The prepared ready-to-eat (RTE) egg rolls in the refrigeration unit are not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Temperature Measuring Devices
Observation: The temperature measuring device in the prep refrigerator was not properly located in the warmest part of the unit.
Correction: Relocate the temperature measuring device to the warmest part of the refrigeration unit to properly represent the ambient air temperature.
|
08/28/2014 | Routine | |
- Food Storage Containers - Identified with Common Name of Food
Observation: Unlabeled food containers.
Correction: Label working containers with the common name of its contents. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient when the consumer has requested that it not be used may result in severe medical consequences. Liquid foods and granular foods may resemble cleaning compounds. The mistaken use of food from an unlabeled container could result in chemical poisoning.
- Critical: Cooling* (corrected on site)
Observation: Chicken noted not being adequately cooled to prevent the growth of harmful bacteria.
Correction: Cool potentially hazardous foods from 135°F to 70°F within 2 hours and within a total of 6 hours from 135°F to 41°F. A longer time for cooling allows an ideal situation for bacterial growth. This has been shown to be the major contributing factor in many foodborne illnesses.
- Cooling Methods (corrected on site)
Observation: The methods used for cooling were not adequate. Chicken is cooling at room temperature.
Correction: Cool foods by the following methods: 1. Placing food in shallow pans 2. Separating food into smaller thinner portions 3. Using rapid chill cooling equipment 4. Stirring the food in a container placed in an ice water bath 5. Using containers that facilitate heat transfer 6. Adding ice as an ingredient 7. Any other method that can effectively accomplish cooling.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site)
Observation: Chicken and tofu on prep refrigerator are cold holding at improper temperatures.
Correction: Cold hold potentially hazardous food at 41°F or below to inhibit the growth of harmful bacteria.
- Handwashing - Using a Handwashing Lavatory (corrected on site) (repeated violation)
Observation: The handwashing facility located in the kitchen is blocked, preventing access by employees for easy handwashing.
Correction: Access to the handwashing facility identified above is to be available during all hours of operation. Remove the large pot lid in it which is preventing its use.
- Distressed Merchandise, Segregation and Location (corrected on site)
Observation: Products for credit, redemption, or return is not being stored in a separate designated area. Dented cans are not kept separate.
Correction: Segregate products for credit, redemption, or return (damage, spoiled or recalled items) from other food, equipment, linens and single-service and single-use articles being used in the establishment to avoid the mistaken use of these items.
|
05/09/2014 | Routine | |
This is a follow-up to check large prep refrigerator temperature. It is now holding food at proper temperatures.
- Temperature Measuring Devices
Observation: There was no temperature measuring device located in the small prep table.
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Handwashing - Using a Handwashing Lavatory (corrected on site)
Observation: The handwashing facility located in the kitchen is blocked, preventing access by employees for easy handwashing.
Correction: Access to the handwashing facility identified above is to be available during all hours of operation. Remove the item in it preventing its use.
- Hand Drying Provision (corrected on site) (repeated violation)
Observation: No disposable towels were provided at the hand washing lavatory in the kitchen.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
|
02/20/2014 | Other | |
Advised not to use prep table for potentially hazardous food until it is holding food at or below 41 degrees F. Advised an accurate thermometer is needed for that unit. Advised used unsifted breading must be refrigerated or discarded after 4 hours. Please contact me when prep refrigerator is repaired and holding foods at safe temperatures.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site) (repeated violation)
Observation: Potentially hazardous food in prep table are cold holding at improper temperatures. Unsifted breading is held out at room temperature. Fried chickens wings on counter are cold holding at improper temperatures.
Correction: Cold hold potentially hazardous food at 41°F or below to inhibit the growth of harmful bacteria.
- Temperature Measuring Devices - Ambient Air and Water (corrected on site)
Observation: The air temperature measuring device (degrees F) located in the prep refrigerator is not accurate.
Correction: Provide a temperature measuring device that is accurate within +/- 3 degrees Fahrenheit in the intended range of use.
- Cooling, Heating, and Holding Capacities
Observation: Prep table is not maintaining potentially hazardous foods 41°F or below.
Correction: Repair or replace to ensure food items are held at the proper cold holding temperature of 41°F or below . Improper food storage temperatures are a major contributing factor to foodborne illness.
- Dressing Rooms - Using Dressing Rooms and Lockers (corrected on site)
Observation: Employees are not using the dressing rooms, designated area or lockers provided. Coat improperly stored.
Correction: Employees that regularly change their clothes in the establishment should use the dressing room or lockers provided.
|
02/11/2014 | Routine | |
- Hair Restraints - Effectiveness
Observation: Employees observed working in the food service area without proper hair restraints.
Correction: Ensure all employees wear hair restraints such as hats, hair coverings or nets, beard restraints, and clothing that covers body hair, that are designed and worn to effectively keep their hair from contacting exposed food, clean equipment, utensils and linens, and unwrapped single-service and single-use articles. This section does not apply to food employees such as counter staff who only serve beverages and wrapped or packaged foods, hostesses, and wait staff if they present a minimal risk of contaminating exposed food
- Food Storage - Clean and Dry Location (corrected on site) (repeated violation)
Observation: Food stored in a location where it is subject to splash, dust or other contamination. (not covered in walk-in refrigerator)
Correction: Store food where it is not exposed to splash, dust, or other contamination to prevent contamination.
- Food Storage - Clean and Dry Location (corrected on site)
Observation: Food stored on the floor or food stored less than 6" above the floor.;Elevate food storage onto approved shelving with minimum 6" legs or casters.
- Critical: Cooling* (corrected on site) (repeated violation)
Observation: Fried chicken noted not being adequately cooled to prevent the growth of harmful bacteria.
Correction: Cool potentially hazardous foods from 135°F to 70°F within 2 hours and within a total of 6 hours from 135°F to 41°F. A longer time for cooling allows an ideal situation for bacterial growth. This has been shown to be the major contributing factor in many foodborne illnesses.
- Critical: Food - Potentially Hazardous Food - Hot Holding* (corrected on site) (repeated violation)
Observation: RIce hot holding at improper temperatures.
Correction: Hot hold potentially hazardous food at 135°F or above to inhibit the growth of harmful bacteria.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site) (repeated violation)
Observation: Cooked shrimp is cold holding at improper temperatures.
Correction: Cold hold potentially hazardous food at 41°F or below to inhibit the growth of harmful bacteria.
- Hand Drying Provision (corrected on site)
Observation: No disposable towels were provided at the hand washing lavatory in the kitchen.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
- Physical Facilities - Cleaning Frequency and Restrictions
Observation: Hoods above cookline noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
|
11/07/2013 | Routine | |
- Food Storage - Clean and Dry Location
Observation: Food stored in a location where it is subject to splash, dust or other contamination. Some food is not covered in walk-in refrigerator and in reach-in refrigerator.
Correction: Store food where it is not exposed to splash, dust, or other contamination to prevent contamination.
- Critical: Cooling* (corrected on site) (repeated violation)
Observation: Chicken noted not being adequately cooled to prevent the growth of harmful bacteria.
Correction: Cool potentially hazardous foods from 135°F to 70°F within 2 hours and within a total of 6 hours from 135°F to 41°F. A longer time for cooling allows an ideal situation for bacterial growth. This has been shown to be the major contributing factor in many foodborne illnesses.
- Cooling Methods (corrected on site) (repeated violation)
Observation: The methods used for cooling were not adequate.
Correction: Cool foods by the following methods: 1. Placing food in shallow pans 2. Separating food into smaller thinner portions 3. Using rapid chill cooling equipment 4. Stirring the food in a container placed in an ice water bath 5. Using containers that facilitate heat transfer 6. Adding ice as an ingredient 7. Any other method that can effectively accomplish cooling.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site)
Observation: Some food in walk-in refrigerator is cold holding at improper temperatures. Operator said that walk-in had gotten too cold and unit was freezing so he turned it off for awhile.
Correction: Cold hold potentially hazardous food at 41°F or below to inhibit the growth of harmful bacteria.
- Non-Food Contact Surfaces
Observation: The nonfood contact surface of the shelves in walk-in refrigerator has accumulations of grime and debris.
Correction: Clean the surface at a frequency necessary to preclude accumulation of soil residues that become encrusted or attract insects and rodents.
- Outer Openings - Protected
Observation: Outer opening of the food establishment is not protected against entry of insects and rodents. There is a small hole in the back screen door.
Correction: Protect the food establishment against the entry of insects and rodents by 1. Filling or closing holes and other gaps along floors, walls, and ceilings, 2. Closed, tight fitting windows, and 3. Solid, self-closing, tight-fitting doors. Insects and rodents are vectors of disease-causing microorganisms which may be transmitted to humans by contamination of food and food-contact surfaces.
- Handwashing Cleanser - Availability (corrected on site)
Observation: Soap was not provided at the hand washing lavatory in the kitchen.
Correction: Hand soap must be provided at all hand washing lavatories to encourage proper hand washing. Hand cleanser must always be present to aid in reducing microorganisms and particulate matter found on hands.
|
08/20/2013 | Routine | |
Reminded breading for raw chicken must not be left out at room temperature unless it is discarded after 4 hours.
- Critical: Demonstration of Knowledge*
Observation: There is no certifed food manager or knowledgeble person in charge present.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Cloths - Wiping Cloths - Use Limitation (corrected on site)
Observation: Wiping cloths improperly stored between use.
Correction: Ensure wet wiping cloths are stored in a chemical sanitizer at the proper concentration between use.
- Cloths - Wiping Cloths - Use Limitation (corrected on site)
Observation: When tested, no sanitizer or a low concentration of chemical sanitizer was found in the wiping cloth bucket storing wiping cloths used on food contact surfaces.
Correction: Provide sanitizer at proper concentration and immerse or expose food contact surfaces to sanitizing solution for adequate time.
- Thawing (corrected on site)
Observation: Improper methods used to thaw meat.
Correction: Thaw potentially hazardous foods by either of the following methods: 1. Under refrigeration that maintains food temperature at 41°F (45°F) 2. Completely submerged under running water at a temperature of 70°F or below with sufficient water velocity to agitate and float off loose particles in an overflow. Ready-to-eat food shall not exceed 41°F and raw animal foods shall not exceed 41°F for more than four hours 3. As part of the cooking process
- Critical: Cooling* (corrected on site) (repeated violation)
Observation: Chicken noted not being adequately cooled to prevent the growth of harmful bacteria.
Correction: Cool potentially hazardous foods from 135°F to 70°F within 2 hours and within a total of 6 hours from 135°F to 41°F. A longer time for cooling allows an ideal situation for bacterial growth. This has been shown to be the major contributing factor in many foodborne illnesses.
- Cooling Methods (corrected on site) (repeated violation)
Observation: The methods used for cooling were not adequate.
Correction: Cool foods by the following methods: 1. Placing food in shallow pans 2. Separating food into smaller thinner portions 3. Using rapid chill cooling equipment 4. Stirring the food in a container placed in an ice water bath 5. Using containers that facilitate heat transfer 6. Adding ice as an ingredient 7. Any other method that can effectively accomplish cooling.
- Critical: Food - Potentially Hazardous Food - Hot Holding* (corrected on site) (repeated violation)
Observation: Chicken stock in wok and fried rice are hot holding at improper temperatures.
Correction: Hot hold potentially hazardous food at 135°F or above to inhibit the growth of harmful bacteria.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site) (repeated violation)
Observation: The prepared ready-to-eat (RTE) food such as egg rolls in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Critical: Equipment and Utensils - Before Use After Cleaning* (corrected on site)
Observation: The food-contact surfaces of the following equipment were not observed sanitized: large bowl in 3 compartment sink.
Correction: After cleaning and rinsing of the food-contact surface, the surface shall be effectively sanitized before coming in contact with food and before use.
|
05/01/2013 | Routine | |
- Critical: Cooling* (corrected on site) (repeated violation)
Observation: Chicken noted not being adequately cooled to prevent the growth of harmful bacteria.
Correction: Cool potentially hazardous foods from 135°F to 70°F within 2 hours and within a total of 6 hours from 135°F to 41°F. A longer time for cooling allows an ideal situation for bacterial growth. This has been shown to be the major contributing factor in many foodborne illnesses.
- Cooling Methods (corrected on site) (repeated violation)
Observation: The methods used for cooling were not adequate.
Correction: Cool foods by the following methods: 1. Placing food in shallow pans 2. Separating food into smaller thinner portions 3. Using rapid chill cooling equipment 4. Stirring the food in a container placed in an ice water bath 5. Using containers that facilitate heat transfer 6. Adding ice as an ingredient 7. Any other method that can effectively accomplish cooling.
- Critical: Food - Potentially Hazardous Food - Hot Holding* (corrected on site)
Observation: Fried rice hot holding at improper temperatures. Chicken stock in large wok is at improper temperature. (operator discarded)
Correction: Rapidly reheat the food to 165°F and maintain at 135°F or above through the hot holding period.
- Temperature Measuring Devices
Observation: There was no temperature measuring device located in several refrigerators.
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Distressed Merchandise, Segregation and Location (corrected on site)
Observation: Products for credit, redemption, or return is not being stored in a separate designated area. Dented cans were stored with other cans of food.
Correction: Segregate products for credit, redemption, or return (damage, spoiled or recalled items) from other food, equipment, linens and single-service and single-use articles being used in the establishment to avoid the mistaken use of these items.
- Dressing Rooms - Using Dressing Rooms and Lockers (corrected on site)
Observation: Employees are not using the dressing rooms, designated area or lockers provided. Clothing and shoes stored on containers of food.
Correction: Employees that regularly change their clothes in the establishment should use the dressing room or lockers provided.
|
02/04/2013 | Routine | |
Restaurant representatives - add corrected or new information about New No. One Chinese Restaurant (01-0880), 5020 Ferrell Parkway #201, Virginia Beach, VA 23464 »