All critical violations were discussed and corrected during inspection. Will follow-up in 10 days on refrigeration unit and dish machines.
- Critical: Eating, Drinking, or Using Tobacco* (corrected on site)
Observation: The employee is storing personal drinks in areas where they may contaminate food, clean equipment, utensils or other items needing protection.
Correction: Provide a designated area where employees may store personal drinks so as not to contaminate exposed food, clean equipment, utensils, and linens, or unwrapped single-service and single-use articles, or other items needing protection.
- Food Storage Containers - Identified with Common Name of Food
Observation: Unlabeled food containers.
Correction: Label working containers with the common name of its contents. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient when the consumer has requested that it not be used may result in severe medical consequences. Liquid foods and granular foods may resemble cleaning compounds. The mistaken use of food from an unlabeled container could result in chemical poisoning.
- Food Storage - Clean and Dry Location (repeated violation)
Observation: Food stored in a location where it is subject to splash, dust or other contamination.
Correction: Store food where it is not exposed to splash, dust, or other contamination to prevent contamination.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site) (repeated violation)
Observation: Ham and tomatoes cold holding at improper temperatures
Correction: Discard the food and ensure that potentially hazardous foods for cold holding are maintained at 41°F or below to inhibit the growth of harmful bacteria.
- Critical: Time as a Public Health Control* (corrected on site) (repeated violation)
Observation: Foods for which time rather than temperature is being used as a control was not labeled or otherwise marked with a 4 hour cook, serve or discard by time.
Correction: Discard food that is not cooked and served or served if ready-to-eat within 4 hours from the point in time when the food is removed from temperature control. Clearly label or otherwise mark the food with a 4-hour cook-serve or serve by time.
- Temperature Measuring Devices (repeated violation)
Observation: There was no temperature measuring device located in the low boy units.
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Equipment - Good Repair and Proper Adjustment (repeated violation)
Observation: Low boy unit was observed in a state of disrepair and damaged: water pooling.
Correction: Repair the low boy to restore a state of condition that allows for proper operation, accuracy, functioning, maintenance, and cleanability per Part IV, Article 1 and 2 of this chapter. If unable to repair the low boy, replace it with one that meets the specifications of Part IV, Article 1 and 2 of this chapter.
- Warewashing - Mechanical Warewashing Equipment, Hot Water Sanitization Temperatures
Observation: The water temperature in the manifold servicing the high temperature ware wash machine was above the maximum allowable level of 194ºF. The thermometer read 196 degrees Fahrenheit.
Correction: Immediately discontinue the use of the machine until it is operating in accordance with minimum requirements. Initiate manual wash, rinse, and sanitize method to properly clean and sanitize equipment and utensils.
- Critical: Warewashing - Manual & Mechanical Warewashing Equipment, Chemical Sanitization - Temperature, pH, Concentration & Hardness* (corrected on site)
Observation: Chlorine sanitizing solution used was not at an acceptable concentration.
Correction: Adjust the chlorine sanitizing solution to a level of at least 50 parts per million when the pH is at 8 or less and the water temperature is 75°F.
- Pests - Controlling Pests* (repeated violation)
Observation: Harborage conditions exist
Correction: Eliminate harborage conditions. Insects and other pests are capable of transmitting disease to man by contaminating food and food-contact surfaces.
- Critical: Toxics - Storage of Toxic Containers* (corrected on site)
Observation: Containers of chemicals not stored separately from insecticides or rodenticides.
Correction: Store detergents, sanitizers, related cleaning or drying agents and caustics, acids, polishes and other chemicals separately from insecticides and rodenticides.
- Critical: Toxics - Storage of Toxic Containers* (corrected on site)
Observation: Containers of chemicals are not properly stored to prevent the contamination of food, equipment, utensils, linens or single service items.
Correction: Containers of @HAZARDOUS PRODUCT@ must be located in an area that is not above food, equipment, utensils, linens or single service items.
|
01/13/2016 | Routine | |
Permit not issued. Will follow-up on food prep refrigeration units on the cook line within 10 days. All critical violations were discussed and corrected during inspection.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Raw food of animal origin holding in a manner that may cause cross contamination of to ready-to-eat food (RTE).
Correction: Separate raw foods during storage, preparation, holding, and display from raw RTE food including other raw food such as fish for sushi or molluscan shellfish, or other raw RTE food such as vegetables, and cooked RTE food.
- Utensils - In-Use - Between-Use Storage (repeated violation)
Observation: In-use utensils improperly stored between use.
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Critical: Food - Potentially Hazardous Food - Hot Holding* (corrected on site)
Observation: Tomato soup hot holding at improper temperatures.
Correction: Rapidly reheat the food to 165°F and maintain at 135°F or above through the hot holding period.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site) (repeated violation)
Observation: Foods on cook line cold holding at improper temperatures
Correction: Discard the food and ensure that potentially hazardous foods for cold holding are maintained at 41°F or below to inhibit the growth of harmful bacteria.
- Critical: Time as a Public Health Control* (corrected on site) (repeated violation)
Observation: Foods on cook line for which time rather than temperature is being used as a control was not labeled or otherwise marked with a 4 hour cook, serve or discard by time.
Correction: Discard food that is not cooked and served or served if ready-to-eat within 4 hours from the point in time when the food is removed from temperature control. Clearly label or otherwise mark the food with a 4-hour cook-serve or serve by time.
- Critical: Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils* (corrected on site) (repeated violation)
Observation: The following equipment food-contact surfaces were observed soiled to sight and touch: Ice machine.
Correction: Clean and sanitize these surfaces for food contact.
- Pests - Controlling Pests* (corrected on site) (repeated violation)
Observation: Harborage conditions exist
Correction: Eliminate harborage conditions. Insects and other pests are capable of transmitting disease to man by contaminating food and food-contact surfaces.
|
09/24/2015 | Routine | |
All critical violations were discussed and corrected after inspection.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site)
Observation: Raw food of animal origin holding in a manner that may cause cross contamination of to ready-to-eat food (RTE).
Correction: Separate raw foods during storage, preparation, holding, and display from raw RTE food including other raw food such as fish for sushi or molluscan shellfish, or other raw RTE food such as vegetables, and cooked RTE food.
- Utensils - In-Use - Between-Use Storage (repeated violation)
Observation: In-use utensils improperly stored between use.
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Cloths - Wiping Cloths - Use Limitation (corrected on site)
Observation: When tested, no sanitizer or a low concentration of chemical sanitizer was found in the wiping cloth bucket storing wiping cloths used on food contact surfaces.
Correction: Provide @SANITIZING AGENTS@ at proper concentration of @SANI CONCENTRATIONS@ and immerse or expose food contact surfaces to sanitizing solution for adequate time.
- Food Storage - Clean and Dry Location (repeated violation)
Observation: Food stored in a location where it is subject to splash, dust or other contamination.
Correction: Store food where it is not exposed to splash or install an approved durable, and cleanable barrier between the splash source and the food to prevent contamination.
- Cooling Methods (repeated violation)
Observation: The methods used for cooling were not adequate.
Correction: Cool foods by the following methods: 1. Placing food in shallow pans 2. Separating food into smaller thinner portions 3. Using rapid chill cooling equipment 4. Stirring the food in a container placed in an ice water bath 5. Using containers that facilitate heat transfer 6. Adding ice as an ingredient 7. Any other method that can effectively accomplish cooling.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site) (repeated violation)
Observation: Tomatoes, cheese, turkey, mozarella cheese, meatloaf, ham, egg yolk, pasta, salmon, and salsa cold holding at improper temperatures
Correction: Discard the food and ensure that potentially hazardous foods for cold holding are maintained at 41°F or below to inhibit the growth of harmful bacteria.
- Critical: Time as a Public Health Control* (corrected on site) (repeated violation)
Observation: Foods for which time rather than temperature is being used as a control was not labeled or otherwise marked with a 4 hour cook, serve or discard by time.
Correction: Discard food that is not cooked and served or served if ready-to-eat within 4 hours from the point in time when the food is removed from temperature control. Clearly label or otherwise mark the food with a 4-hour cook-serve or serve by time.
- Temperature Measuring Devices (repeated violation)
Observation: There was no temperature measuring device located in low boy units.
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Equipment - Good Repair and Proper Adjustment (repeated violation)
Observation: Mechanically vented hood filters not in good repair or have gaps in between filters.
Correction: Repair or replace hood filters and/or eliminate gaps between filters.
- Critical: Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils* (corrected on site)
Observation: The following equipment food-contact surfaces were observed soiled to sight and touch: ice machine.
Correction: Clean and sanitize these surfaces for food contact.
- Equipment, Utensils, Linens, and Single-Service and Single-Use Articles (repeated violation)
Observation: Single service items observed unprotected from contamination.
Correction: Store single service items in its original protective packaging or inverted in an approved dispenser.
- Handwashing - Using a Handwashing Lavatory - No Other Purpose
Observation: The handwash station at the pizza station is being used for purposes other than washing hands.
Correction: The handwash facility identified above is to be used for washing hands only
- Handwashing Signage/Handwashing Facilities
Observation: A sign or poster that notifies food employees to wash their hands is not provided at all lavatories used by food employees
Correction: Provide a sign or poster that notifies food employees to wash their hands at all handwashing lavatories used by food employees.
- Physical Facilities - Cleaning Frequency and Restrictions
Observation: Walk-in freezer noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
- Pests - Controlling Pests*
Observation: Harborage conditions exist
Correction: Eliminate harborage conditions. Insects and other pests are capable of transmitting disease to man by contaminating food and food-contact surfaces.
|
06/11/2015 | Routine | |
Standardization inspection conducted. Critical violations discussed and corrected. Handbasin has been removed from pizza prep area.
- Critical: Hands - When to Wash* (corrected on site)
Observation: A food employee failed to wash his or her hands before engaging in food preparation, after touching bare human body parts, after coughing, sneezing, eating, after handling soiled utensils or after engaging in any activity which may have contaminated his/her hands.
Correction: Instruct food employees to clean their hands and exposed portions of their arms immediately before engaging in food preparation including working with exposed food, clean equipment and utensils, and unwrapped single-service and single-use articles and during food preparation, as often as necessary to remove soil and contamination and to prevent cross contamination when changing task.
- Jewelry - Prohibition
Observation: Employees wearing jewelry on their arms and hands while preparing food.
Correction: Ensure employees are not wearing jewelry on their arms and hands while preparing food. This section does not apply to a plain ring such as a wedding band.
- Hair Restraints - Effectiveness
Observation: Employees observed working in the food service area without proper hair restraints.
Correction: Ensure all employees wear hair restraints such as hats, hair coverings or nets, beard restraints, and clothing that covers body hair, that are designed and worn to effectively keep their hair from contacting exposed food, clean equipment, utensils and linens, and unwrapped single-service and single-use articles. This section does not apply to food employees such as counter staff who only serve beverages and wrapped or packaged foods, hostesses, and wait staff if they present a minimal risk of contaminating exposed food
- Critical: Package Integrity* (corrected on site)
Observation: Food packages are not in good condition or the integrity of the package contents are not protected from adulteration or potential contaminants (ex: dented food cans)
Correction: Discard or return to distributor any food packages that are not in good condition or the integrity of the package contents are not protected from adulteration or potential contaminants.
- Food Storage Containers - Identified with Common Name of Food (repeated violation)
Observation: Unlabeled food containers.
Correction: Label working containers with the common name of its contents. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient when the consumer has requested that it not be used may result in severe medical consequences. Liquid foods and granular foods may resemble cleaning compounds. The mistaken use of food from an unlabeled container could result in chemical poisoning.
- Utensils - In-Use - Between-Use Storage
Observation: In-use utensils improperly stored between use.
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Food Storage - Clean and Dry Location
Observation: Food stored in a location where it is subject to splash, dust or other contamination.
Correction: Store food where it is not exposed to splash, dust, or other contamination to prevent contamination.
- Records - Creation and Retention (corrected on site)
Observation: No written agreement or statement from the supplier or aquaculturist stipulating that the fish, such as salmon, were raised (open water in net pens
Correction: or land-based operations such as farm and tanks) and fed formulated feed, such as pellets that contain no live parasides infective to the aquacultured fish.
- Cooling Methods
Observation: The methods used for cooling were not adequate.
Correction: Cool foods by the following methods: 1. Placing food in shallow pans 2. Separating food into smaller thinner portions 3. Using rapid chill cooling equipment 4. Stirring the food in a container placed in an ice water bath 5. Using containers that facilitate heat transfer 6. Adding ice as an ingredient 7. Any other method that can effectively accomplish cooling.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site)
Observation: Temperature controlled foods at cookline cold holding at improper temperatures
Correction: Discard the food and ensure that potentially hazardous foods for cold holding are maintained at 41°F or below to inhibit the growth of harmful bacteria.
- Critical: Time as a Public Health Control* (corrected on site)
Observation: Garlic and oil for which time rather than temperature is being used as a control was not labeled or otherwise marked with a 4 hour cook, serve or discard by time.
Correction: Discard food that is not cooked and served or served if ready-to-eat within 4 hours from the point in time when the food is removed from temperature control. Clearly label or otherwise mark the food with a 4-hour cook-serve or serve by time.
- Critical: Time as a Public Health Control* (corrected on site)
Observation: No written procedures for the use of time as a public health control with potentially hazardous foods.
Correction: Provide written procedures for the use of time as a public health control. The procedures must include the following steps or practices: a. Food must be marked with the time within which it must be cooked, served or discarded. b. The food is served or discarded within four hours from the time when the food is removed from temperature control c. Food in unmarked containers or packages, or for which the time expires is discarded and d. Written procedures are maintained in the food establishment and made available to the regulatory authority upon request e. Once time is implemented as a control measure for potentially hazardous food, no other measures may be substituted.
- Critical: Food - Consumption of Raw or Undercooked Animal Foods (corrected on site)
Observation: A review of the menu with the foodservice operator indicates that there is not a proper consumer advisory for the animal foods that may be served raw and/or undercooked
Correction: If an animal food such as beef, eggs, fish, lamb, milk, pork, poultry, or shellfish is served or sold raw or undercooked the permit holder shall inform consumers of the significantly increased risk of consuming such foods by way of a disclosure and reminder using brochures, deli case or menu advisories, label statements, table tents, placards, or other effective written means.
- Temperature Measuring Devices
Observation: There was no temperature measuring device located in the low boy refrigerator.
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Responsibilities of Owner or Proprietor (corrected on site)
Observation: Absence of no-smoking signs or international no-smoking signs in non-smoking area.
Correction: Post of no-smoking signs or international no-smoking signs in non-smoking area. These can be found online at www.vdh.virginia.gov/breatheeasy
- Sanitizing Solutions, Testing Devices
Observation: There is no properly working test kit provided in the facility for monitoring the concentration of the chemical sanitizing solutions.
Correction: Obtain a quat test kit so that employees can accurately monitor the concentration of the sanitizing solutions and maintain them at a safe and effective level.
- Equipment - Cutting Surfaces
Observation: The cutting boards are heavily scratched and scored. The food contact surface is no longer easily cleaned and sanitized due to condition.
Correction: Resurface or discard and replace the cutting boards to provide a food contact surface that is smooth, easily cleaned and sanitized.
- Equipment, Utensils, Linens, and Single-Service and Single-Use Articles
Observation: Single service items observed unprotected from contamination.
Correction: Store single service items in its original protective packaging or inverted in an approved dispenser.
- Backflow Prevention Device, Design Standard
Observation: The backflow or backsiphonage prevention device installed on the mop sink is not identified as meeting standards set by the American Society of Sanitary Engineering.
Correction: Provide the approved backflow or backsiphonage device for the specific application and type of device to prevent contamination of the drinking water system.
- Critical: Backflow Prevention Device, When Required* (corrected on site)
Observation: Backflow or backsiphonage prevention device not available on threaded faucet as required by law. Hose with sprayer connected to prep sink.
Correction: Provide a backflow or backsiphonage prevention device on all threaded faucets.
- Critical: Handwashing Lavatory* (corrected on site)
Observation: There is no handwash lavatory at pizza prep area, preventing routine handwashing by food workers.
Correction: Install an additional handwash lavatory at pizza prep area to allow convenient use by food workers. Prior to installing additional plumbing fixtures the permit holder must apply and gain approval through the necessary regulatory agencies.
- Light Bulbs Protective Shielding
Observation: Light bulbs in wait area not shielded, coated, or otherwise shatter-resistant.
Correction: Shield or replace light bulb with a coated or shatter-resistant bulb.
- Insect Control Devices - Design and Installation
Observation: Insect control device is located over doorway to service area where dead insects may be impelled or fall.
Correction: Install the insect control device away from a food preparation area so that dead insects and insect fragments are prevented from being impelled onto or falling on exposed food, clean equipment, utensils, and linens, and unwrapped single service and single use articles. Exposed food and food-contact surfaces must be protected from contamination by insects or insect parts. Installation of the device over food preparation areas or in close proximity to exposed food and/or food contact surfaces could allow dead insects and/or insect parts to be impelled by the electric charge, fall, or be blown from the device onto food or food-contact surfaces.
- Physical Facilities in Good Repair
Observation: Ceiling in kitchen service area is not maintained in good repair
Correction: Maintain physical facilities in good repair. Poor repair and maintenance compromises the functionality of the physical facilities.
- Critical: Toxics - Common Name/working Containers of Toxics* (corrected on site)
Observation: Working containers of toxic chemicals are not properly labeled.
Correction: Working containers of toxic items are to be properly labeled with contents. Identification of these containers with the common name of the material helps prevent the dangerous misuse of the contents.
|
03/10/2015 | Routine | |
Observations discussed and/or corrected during inspection. Discussed watching cold holding temperatures along prep line due to grill directly across. Employee health sheets for individual employees are on file on the computer.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation (corrected on site)
Observation: Observed that food was not protected from cross contamination because it was not in packages, covered containers, or wrapped.
Correction: Prevent cross contamination by storing food in packages, covered containers, or wrappings.
- Equipment - Good Repair and Proper Adjustment
Observation: The door gasket to the 2 door reach in is in poor repair.
Correction: Repair or replace the door gasket in accordance with the manufacturer's specifications.
- Floors, Walls, and Ceilings - Cleanability
Observation: Floor or floor covering in dishmachine area is not smooth and easily cleanable, tile is cracked/missing.
Correction: Repair or replace floor or floor covering to make it smooth and easily cleanable.
|
08/06/2014 | Routine | |
Manager emailed EHS a picture of the dishmachine, which has received a new fuse and circuit board for the booster. Dishmachine wash cycle is at 158 degrees, rinse cycle is at 187 degrees. Please see note to file for picture of dishmachine gauges.
- Physical Facilities in Good Repair (repeated violation)
Observation: Tile in dishmachine area is not maintained in good repair
Correction: Maintain physical facilities in good repair. Poor repair and maintenance compromises the functionality of the physical facilities.
|
05/06/2014 | Follow-up | |
Observations discussed and/or corrected during inspection. Manager will contact EHS when Ecolab has come out to repair dishmachine to rinse at 180 degrees. Three compartment sink has been set up to proper sanitize food contact surfaces until repair has been made. Discussed using lids to cover foods in prep units after lunch rush to maintain foods in a safe temperature zone.
- Food Storage Containers - Identified with Common Name of Food (corrected on site)
Observation: Unlabeled food containers.
Correction: Label working containers with the common name of its contents. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient when the consumer has requested that it not be used may result in severe medical consequences. Liquid foods and granular foods may resemble cleaning compounds. The mistaken use of food from an unlabeled container could result in chemical poisoning.
- Cloths - Wiping Cloths - Use Limitation (corrected on site)
Observation: Wiping cloths improperly stored between use.
Correction: Ensure wet wiping cloths are stored in a chemical sanitizer at the proper concentration between use.
- Thawing (corrected on site)
Observation: Improper methods used to thaw seafood.
Correction: Thaw potentially hazardous foods by either of the following methods: 1. Under refrigeration that maintains food temperature at 41°F (45°F) 2. Completely submerged under running water at a temperature of 70°F or below with sufficient water velocity to agitate and float off loose particles in an overflow. Ready-to-eat food shall not exceed 41°F and raw animal foods shall not exceed 41°F for more than four hours 3. As part of the cooking process
- Critical: Equipment and Utensils - Hot Water and Chemical Sanitizing*
Observation: Due to improper operation of the mechanical warewashing machine, equipment food-contact surfaces and utensils are not sanitized after cleaning. (See 12 VAC 5-421-1680)
Correction: Repair the unit so that achieving a utensil surface temperature of 160°F can be measured by an irreversible registering temperature indicator (e.g. thermolabel and maximum registering thermometer). Discontinue use of mechanical warewashing machine and convert to use of 3-vat sink wash, rinse and chemical sanitization. Use single-service items as deemed necessary if not capable of effective manual washing, rinsing, and sanitization of food-contact surfaces.
- Physical Facilities in Good Repair
Observation: Tile in dishmachine area is not maintained in good repair
Correction: Maintain physical facilities in good repair. Poor repair and maintenance compromises the functionality of the physical facilities.
|
04/29/2014 | Routine | |
Observations discussed and corrected during inspection. No critical violations!
- Food - Miscellaneous Sources of Contamination (corrected on site)
Observation: Food storage container stored on top of raw hamburger patties.
Correction: Protect food from miscellaneous sources of contamination.
- Equipment and Utensils - Multiuse, Characteristics (corrected on site)
Observation: The food contact surface of the scoop handles is not durable, nonabsorbent, easily cleanable, resistant to pitting (plugs missing from scoops).
Correction: Repair or replace the scoop handles to permit easy cleaning and prevent the migration of deleterious substances, or transference of colors, odors, or tastes to food.
- Temperature Measuring Devices (corrected on site) (repeated violation)
Observation: There was no temperature measuring device located in the reach in refrigerators.
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
|
02/05/2014 | Routine | |
EHS was contacted by manager via email on November 7, 2013 at 10:07 AM stating that the 2 door refrigeration unit was repaired and has been maintained an ambient air temperature of 36 degrees for the past 24 hours. Also, a temperature log has been put to use to monitor as well.
No violation noted during this evaluation. | 11/07/2013 | Other | |
Observations discussed and/or corrected during inspection. Temperature Controlled for Safety Foods that were cold holding improperly were voluntarily discarded. Repair service company has been contacted to repair refrigeration unit. Equipment temperature log given to manager to record temperatures of units if establishment decides to do so. Manager will contacted EHS when refrigeration unit has been repaired and cold holding properly. Observed facility in good sanitary condition with good date marking practices! Permit issued.
- Cloths - Wiping Cloths - Use Limitation
Observation: Wiping cloths improperly stored between use.
Correction: Ensure wet wiping cloths are stored in a chemical sanitizer at the proper concentration between use.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site) (repeated violation)
Observation: Deli meats and cheese's cold holding at improper temperatures
Correction: Relocate food to a refrigeration unit that is capable of maintaining food storage at 41°F or below.
- Temperature Measuring Devices
Observation: There was no temperature measuring device located in all refrigeration units.
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Cooling, Heating, and Holding Capacities (corrected on site) (repeated violation)
Observation: Two door reach in refrigerator is not maintaining potentially hazardous foods 41°F or below.
Correction: Repair or replace the refrigerator to ensure food items are held at the proper cold holding temperature of 41°F or below . Improper food storage temperatures are a major contributing factor to foodborne illness.
|
11/05/2013 | Routine | |
Violations discussed and/or corrected during inspection. Foods that were cold holding above 41 degrees have been relocated. Unit will not store potentially hazardous foods until it is able to reach the required 41 degrees or below. Individual employee health sheets given to CFM to have signed by each employee.
- Critical: Food Contact with Equipment and Utensils* (corrected on site)
Observation: Sprite soda cans in contact with ice in ice machine that have not been cleaned or sanitized as required.
Correction: Use only cleaned and sanitized utensils or equipment during food preparation.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site)
Observation: Potentially hazardous foods cold holding at improper temperatures
Correction: Relocate food to a refrigeration unit that is capable of maintaining food storage at 41°F or below.
- Cooling, Heating, and Holding Capacities
Observation: Low boy refrigeration unit is not maintaining potentially hazardous foods 41°F or below.
Correction: Repair or replace the equipment to ensure food items are held at the proper cold holding temperature of 41°F or below . Improper food storage temperatures are a major contributing factor to foodborne illness.
|
07/31/2013 | Routine | |
Observations discussed for correction with Assistant Manager. NO CFM AVAILABLE AT TIME OF INSPECTION. CFM required during operation hours..
- Critical: Person in Charge - Assignment of Responsibility*
Observation: The person in charge was not available at the time of inspection.
Correction: The permit holder shall designate a person in charge who is authorized to monitor and manage all food establishment operations and who is authorized to take actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (repeated violation)
Observation: The prepared ready-to-eat (RTE) sliced tomatoes in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Equipment - Good Repair and Proper Adjustment
Observation: Walk-in freezer was observed in a condition that prevents necessary maintenance and easy cleaning
Correction: ice build-up.
- Equipment - Good Repair and Proper Adjustment
Observation: The door gasket to the walk-in is in poor repair.
Correction: Repair or replace the door gasket in accordance with the manufacturer's specifications.
- Equipment - Cutting Surfaces
Observation: The cutting board(s) along the prep-line are heavily scratched and scored. The food contact surface is no longer easily cleaned and sanitized due to condition.
Correction: Resurface or discard and replace the cutting boards to provide a food contact surface that is smooth, easily cleaned and sanitized.
|
04/24/2013 | Routine | |
Discussed observations with PIC.
- Utensils - In-Use - Between-Use Storage
Observation: In-use utensils improperly stored between use (ice scoop handle in the ice).
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Cloths - Wiping Cloths - Use Limitation (corrected on site) (repeated violation)
Observation: Wiping cloths improperly used.
Correction: Ensure cloths used for wiping food spills are not used for any other purpose.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking*
Observation: The ready-to-eat (RTE) commercially processed sliced tomatoes in the refrigeration unit was not properly dated for disposition after opening.
Correction: Mark a "consume by" date on commercially processed RTE foods at the time the original container is opened. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Warewashing - Mechanical Warewashing Equipment, Hot Water Sanitization Temperatures
Observation: The water temperature in the manifold servicing the high temperature ware wash machine was above the maximum allowable level of 194ºF. The thermometer read 200 degrees F.
Correction: Immediately discontinue the use of the machine until it is operating in accordance with minimum requirements. Initiate manual wash, rinse, and sanitize method to properly clean and sanitize equipment and utensils.
- Handwashing - Using a Handwashing Lavatory - No Other Purpose
Observation: The handwash station at the bar is being used as a dump station.
Correction: The handwash facility identified above is to be used for washing hands only
- Mops - Drying Mops
Observation: Mops not hung up to air dry.
Correction: Wet use maintenance items such as mops must be hung in a position that allows them to air dry so they are not allowed to grow contamination which can then be spread through the establishment at the next use.
|
01/16/2013 | Routine | |
Restaurant representatives - add corrected or new information about Baker's Crust Bread Market (01-0940), 1628 Laskin Road #704, Virginia Beach, VA 23451 »