Walk-in cooler was adequately repaired. Cooling products is still an issue - 5 containers were discarded (3 containers of mole, 2 containers of chicken broth). Cooling needs to be done via ice wand/ice bath/shallow pans. Cooling products should not be placed in plastic containers until a temperature of 41 degrees is reached. 135 to 71 in 2 hours
- Critical: Cooling* (corrected on site) (repeated violation)
Observation: Mole noted not being adequately cooled to prevent the growth of harmful bacteria.
Correction: Cool potentially hazardous foods from 135°F to 70°F within 2 hours and within a total of 6 hours from 135°F to 41°F. A longer time for cooling allows an ideal situation for bacterial growth. This has been shown to be the major contributing factor in many foodborne illnesses.
- Cooling Methods (repeated violation)
Observation: The methods used for cooling were not adequate.
Correction: Cool foods by the following methods: 1. Placing food in shallow pans 2. Separating food into smaller thinner portions 3. Using rapid chill cooling equipment 4. Stirring the food in a container placed in an ice water bath 5. Using containers that facilitate heat transfer 6. Adding ice as an ingredient 7. Any other method that can effectively accomplish cooling.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (repeated violation)
Observation: The prepared ready-to-eat (RTE) @FOOD@ in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
|
04/21/2015 | Follow-up | |
Instructed PIC to have walk-in repaired immediately. Walk-in is not to be used for cold holding until proper temperature can be maintained. All cold holding is to be done in walk-in freezer.
- Cooling Methods (repeated violation)
Observation: The methods used for cooling were not adequate.
Correction: Cool foods by the following methods: 1. Placing food in shallow pans 2. Separating food into smaller thinner portions 3. Using rapid chill cooling equipment 4. Stirring the food in a container placed in an ice water bath 5. Using containers that facilitate heat transfer 6. Adding ice as an ingredient 7. Any other method that can effectively accomplish cooling.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (repeated violation)
Observation: Refried beans cold holding at improper temperatures
Correction: Discard the food and ensure that potentially hazardous foods for cold holding are maintained at 41°F or below to inhibit the growth of harmful bacteria.
- Temperature Measuring Devices (repeated violation)
Observation: There was no temperature measuring device located in the walk-in cooler or salsa cooler.
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Hand Drying Provision (repeated violation)
Observation: No disposable towels were provided at the hand washing lavatory in middle of kitchen.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
|
04/14/2015 | Follow-up | |
Spoke with PIC regarding walk-in cooling unit. Items to be cooled or cold held will be moved to walk-in freezer. Also spoke to PIC regarding ways to properly cool food, specifically refried beans. Facility is very clean and maintained.
- Cooling Methods
Observation: The methods used for cooling were not adequate.
Correction: Cool foods by the following methods: 1. Placing food in shallow pans 2. Separating food into smaller thinner portions 3. Using rapid chill cooling equipment 4. Stirring the food in a container placed in an ice water bath 5. Using containers that facilitate heat transfer 6. Adding ice as an ingredient 7. Any other method that can effectively accomplish cooling.
- Critical: Food - Potentially Hazardous Food - Cold Holding*
Observation: Refried beans cold holding at improper temperatures
Correction: Discard the food and ensure that potentially hazardous foods for cold holding are maintained at 41°F or below to inhibit the growth of harmful bacteria.
- Temperature Measuring Devices (repeated violation)
Observation: There was no temperature measuring device located in the walk-in cooler or salsa cooler.
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Hand Drying Provision
Observation: No disposable towels were provided at the hand washing lavatory in middle of kitchen.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
|
04/06/2015 | Routine | |
Kitchen very clean and well maintained.
- Critical: Cooling* (corrected on site)
Observation: Shredded chicken noted not being adequately cooled to prevent the growth of harmful bacteria.
Correction: Cool potentially hazardous foods from 135°F to 70°F within 2 hours and within a total of 6 hours from 135°F to 41°F. A longer time for cooling allows an ideal situation for bacterial growth. This has been shown to be the major contributing factor in many foodborne illnesses.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site)
Observation: The prepared ready-to-eat Chilli Rellenos & Carnitas in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Critical: Toxics - Common Name/working Containers of Toxics* (corrected on site)
Observation: Working containers of sanitizer are not properly labeled.
Correction: Working containers of toxic items are to be properly labeled with contents. Identification of these containers with the common name of the material helps prevent the dangerous misuse of the contents.
|
02/20/2014 | Routine | |
- Critical: Demonstration of Knowledge* (corrected on site)
Observation: The person in charge failed to explain the significance of the relationship between the holding time and temperature of potentially hazardous food and foodborne illness.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled. PIC is registered for a food safety class.
|
02/22/2013 | Follow-up | |
PIC will register for food safety class within 10 days. Information of available classes will be provided. Kitchen is very clean and well maintained.
- Critical: Demonstration of Knowledge*
Observation: The person in charge failed to explain the significance of the relationship between the holding time and temperature of potentially hazardous food and foodborne illness.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Temperature Measuring Devices
Observation: There was no temperature measuring device located in the walk-in cooler, prep unit by grill, and double door prep unit.
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Outer Openings - Protected
Observation: Outer opening of the food establishment in storage area is not protected against entry of insects and rodents.
Correction: Protect the food establishment against the entry of insects and rodents by 1. Filling or closing holes and other gaps along floors, walls, and ceilings, 2. Closed, tight fitting windows, and 3. Solid, self-closing, tight-fitting doors. Insects and rodents are vectors of disease-causing microorganisms which may be transmitted to humans by contamination of food and food-contact surfaces.
|
02/05/2013 | Routine | |
Restaurant representatives - add corrected or new information about El Charro Mexican Grill #2, 302 S Locust Street, Floyd, VA 24091 »