- Critical: Hands - Preventing Contamination from Hands* (corrected on site)
Observation: Employees observed handling ready-to-eat (RTE) food with their bare hands.
Correction: Provide suitable utensils such as deli tissue, spatulas, tongs, single-use gloves, or dispensing equipment to handle RTE food to prevent contamination from hands.
- Utensils - In-Use - Between-Use Storage (corrected on site)
Observation: In-use utensils improperly stored between use. Utensils were in water with a temperature of 105°F.
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Temperature - Food Temperature Measuring Devices - Provided
Observation: The Person in Charge could not produce an appropriate food temperature measuring device to verify cooking temperatures of thin foods.
Correction: A temperature measuring device with a suitable small-diameter probe that is designed to measure the temperature of thin masses shall be provided and readily accessible to accurately measure the temperature in thin foods.
- Handwashing - Using a Handwashing Lavatory (corrected on site)
Observation: The handwashing facility was blocked, preventing access by employees for easy handwashing.
Correction: All handwashing facilities should be available at all hours of operation.
- Handwashing Cleanser - Availability (repeated violation)
Observation: Soap was not provided at some hand washing lavatories.
Correction: Hand soap must be provided at all hand washing lavatories to encourage proper hand washing. Hand cleanser must always be present to aid in reducing microorganisms and particulate matter found on hands.
|
12/29/2015 | Routine | |
-The walk-in and the Fagor sandwich prep were holding food right at 41 degrees. Monitor them because 41 degrees is the maximum temperature to cold hold safely. The units may need adjusted, cleaned, or serviced soon.
- The Frigidaire refrigerator/freezer at the front desk is currently holding above 41 degrees, but no temperature sensitive foods are being stored in it. If that changes, please repair the unit so it cold holds food properly.
- Check the dish machine daily to ensure it is working properly
- Critical: Package Integrity*
Observation: Food packages are not in good condition or the integrity of the package contents are not protected from adulteration or potential contaminants (ex: dented food cans)
Correction: Discard or return to distributor any food packages that are not in good condition or the integrity of the package contents are not protected from adulteration or potential contaminants.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site)
Observation: Raw food of animal origin holding in a manner that may cause cross contamination of to ready-to-eat food (RTE). (Over stacked raw steak for steak and cheese observed cross-contaminating ham stored beside it in the sandwich prep.)
Correction: Separate raw foods during storage, preparation, holding, and display from raw RTE food including other raw food such as fish for sushi or molluscan shellfish, or other raw RTE food such as vegetables, and cooked RTE food.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site)
Observation: The prepared ready-to-eat (RTE) food in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Sanitizing Solutions, Testing Devices
Observation: There is no properly working test kit provided in the facility for monitoring the concentration of the chemical sanitizing solutions.( Ammonia based sanitizer at the 3 vat sink.)
Correction: Obtain a Quat Ammonia test kit so that employees can accurately monitor the concentration of the sanitizing solutions and maintain them at a safe and effective level.
- Critical: Warewashing - Manual & Mechanical Warewashing Equipment, Chemical Sanitization - Temperature, pH, Concentration & Hardness* (corrected on site)
Observation: Chlorine sanitizing solution used was not at an acceptable concentration.
Correction: Adjust the chlorine sanitizing solution to a level of at least 50 parts per million when the pH is at 10 or less and the water temperature is 100°F.
- Handwashing Cleanser - Availability (corrected on site)
Observation: Soap was not provided at the hand washing lavatory in the kitchen area.
Correction: Hand soap must be provided at all hand washing lavatories to encourage proper hand washing. Hand cleanser must always be present to aid in reducing microorganisms and particulate matter found on hands.
- Hand Drying Provision (corrected on site) (repeated violation)
Observation: No disposable towels were provided at the hand washing lavatory in the kitchen area.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
|
08/13/2014 | Routine | |
All Exposed wood must be sealed and painted with White Semi-Gloss Paint.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (repeated violation)
Observation: Product stored in Fagor 3-Door Cooler w Counter / Fagor Prep Unit (sandwich) / Walk-In Cooler observed cold holding at improper temperatures.
Correction: Cold hold potentially hazardous food at 41°F or below to inhibit the growth of harmful bacteria.
- Hand Drying Provision (corrected on site)
Observation: No disposable towels were provided at the hand washing lavatory in the kitchen.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
|
08/26/2013 | Routine | |
- Critical: Cooling* (corrected on site) (repeated violation)
Observation: Tomato Sauce noted not being adequately cooled to prevent the growth of harmful bacteria.
Correction: Cool potentially hazardous foods from 135°F to 70°F within 2 hours and from 70°F to 41°F or below within 4 hours. A longer time for cooling allows an ideal situation for bacterial growth. This has been shown to be the major contributing factor in many foodborne illnesses.
- Cooling Methods (repeated violation)
Observation: The methods used for cooling were not adequate.
Correction: Cool foods by the following methods: 1. Placing food in shallow pans 2. Separating food into smaller thinner portions 3. Using rapid chill cooling equipment 4. Stirring the food in a container placed in an ice water bath 5. Using containers that facilitate heat transfer 6. Adding ice as an ingredient 7. Any other method that can effectively accomplish cooling.
|
02/24/2012 | Follow-up | |
Ice machine drainline need to be properly plumbed.
- Critical: Eating, Drinking, or Using Tobacco*
Observation: The staff are drinking from an uncovered container in the food preparation area.
Correction: Employees may drink from a closed beverage container if the container is handled to prevent contamination of (1) The employee's hands, (2) The container, and (3) Exposed food, clean equipment, utensils, and linens, and unwrapped single-service and single-use articles.
- Cooling Methods
Observation: The methods used for cooling were not adequate.
Correction: Cool foods by the following methods: 1. Placing food in shallow pans 2. Separating food into smaller thinner portions 3. Using rapid chill cooling equipment 4. Stirring the food in a container placed in an ice water bath 5. Using containers that facilitate heat transfer 6. Adding ice as an ingredient 7. Any other method that can effectively accomplish cooling.
- Critical: Food - Potentially Hazardous Food - Cold Holding*
Observation: Product stored in the Fagor Prep Units and Walk-In Cooler cold holding at improper temperatures.
Correction: Cold hold potentially hazardous food at 41°F or below to inhibit the growth of harmful bacteria.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (repeated violation)
Observation: The prepared ready-to-eat (RTE) pasta noodles, lasagna, tomato sauce, etc. - in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking*
Observation: The ready-to-eat (RTE) commercially processed deli meats in the refrigeration unit was not properly dated for disposition after opening.
Correction: Mark a "consume by" date on commercially processed RTE foods at the time the original container is opened. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Plumbing System Maintained in Good Repair
Observation: Faucet at 3-Bay sink in poor repair.
Correction: Repair and maintain all plumbing components and fixtures.
- Handwashing Cleanser - Availability (repeated violation)
Observation: Soap was not provided at the hand washing lavatory at the hand sinks.
Correction: Hand soap must be provided at all hand washing lavatories to encourage proper hand washing. Hand cleanser must always be present to aid in reducing microorganisms and particulate matter found on hands.
- Hand Drying Provision (repeated violation)
Observation: No disposable towels were provided at the hand washing lavatory at the hand sinks.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
|
02/13/2012 | Routine | |
Handouts provided to the facility on cooling and consumer advisory.
Additional handouts will be provided in additional languages.
- Critical: Cooling*
Observation: Sauces noted not being adequately cooled to prevent the growth of harmful bacteria.
Correction: Cool potentially hazardous foods from 135°F to 70°F within 2 hours and from 70°F to 41°F or below within 4 hours. A longer time for cooling allows an ideal situation for bacterial growth. This has been shown to be the major contributing factor in many foodborne illnesses.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking*
Observation: The prepared ready-to-eat (RTE) foods in the refrigeration unit are not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Critical: Food - Consumption of Raw or Undercooked Animal Foods
Observation: A review of the menu with the foodservice operator indicates that there is no consumer advisory for the hamburgers that may be served raw and/or undercooked.
Correction: If an animal food such as beef, eggs, fish, lamb, milk, pork, poultry, or shellfish is served or sold raw or undercooked the permit holder shall inform consumers of the significantly increased risk of consuming such foods by way of a disclosure and reminder using brochures, deli case or menu advisories, label statements, table tents, placards, or other effective written means.
- Handwashing Cleanser - Availability
Observation: Soap was not provided at the hand washing lavatory in the kitchen.
Correction: Hand soap must be provided at all hand washing lavatories to encourage proper hand washing. Hand cleanser must always be present to aid in reducing microorganisms and particulate matter found on hands. NOTE: PIC stated that soap was to be delivered with the supplies today.
- Hand Drying Provision
Observation: No disposable towels were provided at the hand washing lavatory in the kitchen.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials. NOTE: PIC stated that paper towels were to be delivered with the supplies today.
|
07/25/2011 | Risk Factor Assessment | |
Restaurant representatives - add corrected or new information about Castiglia's Italian Restaurant And Pizza, 33820 Old Valley Pike, Strasburg, VA 22657 »