Rice scoop observed improperly stored in a container of water at room temperature. Continue to clean floor/wall surfaces frequently. A new grease trap has been installed.
- Cooling, Cooked Food (corrected on site)
Observation: Small container of rice in the 2-door reach-in prepared the previous day observed at improper temperature (69 F). Product was discarded by the person in charge.
Correction: Cooked time/temperature control for safety food shall be cooled: (1) Within 2 hours from 57ºC (135ºF) to 21ºC (70ºF)
- Time/Temperature Control for Safety Food, Cold Holding, Eggs (corrected on site) (repeated violation)
Observation: Container of raw shell eggs observed improperly stored at room temperature on the cook-line counter. Product was placed back under refrigeration by the person in charge.
Correction: Eggs that have not been treated to destroy all viable Salmonellae shall be stored in refrigerated equipment that maintains an ambient air temperature of 7ºC (45ºF) or less.
- Cleaning of Plumbing Fixtures (corrected on site) (repeated violation)
Observation: Handsink basin by the back mop sink observed in need of cleaning.
Correction: Plumbing fixtures such as handwashing sinks, toilets, and urinals shall be cleaned as often as necessary to keep them clean and maintained and used as specified under section 5-205.11. Handwashing facilities are critical to food protection and must be maintained in operating order at all times so they will be used.
|
12/09/2015 | Risk Factor | |
The kitchen cook-line hood vents were observed in need of cleaning. The men's rest-room urinal was observed not properly flushing and in need of repair. The establishment has recently switched to a new pest control company. Continue to clean the facility frequently and daily. Remember to store single-service items and food items at least 6 inches above the floor. Outside waste receptacle lids were observed closed during the time of inspection.
- Reheating for Hot Holding
Observation: Container of peanut sauce (108 F) observed not reheated to proper temperature before hot holding (product was reheated to 165 + by the person in charge).
Correction: Time/temperature control for safety food that is cooked, cooled and reheated for hot holding shall be reheated so that all parts of the food reach a temperature of at least 74ºC (165ºF) for 15 seconds. When food is held, cooled, and reheated in a food establishment, there is an increased risk from contamination caused by personnel, equipment, procedures, or other factors. If food is held at improper temperatures for enough time, pathogens have the opportunity to multiply to dangerous numbers. Proper reheating provides a major degree of assurance that pathogens will be eliminated. The potential for growth of pathogenic bacteria is greater in reheated cooked foods than in raw foods. This is because spoilage bacteria, which inhibit the growth of pathogens by competition on raw product, are killed during cooking. Subsequent recontamination will allow pathogens to grow without competition if temperature abuse occurs.
- Sanitizers, Criteria/Chemicals for Food Contact Surfaces (corrected on site)
Observation: Chlorine sanitizer in the wiping cloth bucket observed at a concentration greater than 200 parts per million (solution was diluted by the person in charge).
Correction: Chemical sanitizers and other chemical antimicrobials applied to food-contact surfaces shall meet the requirements specified in 40 CFR 180.940 Tolerance exemptions for active and inert ingredients for use in antimicrobial formulations (food-contact surface sanitizing solutions). Chemical sanitizers are included with poisonous or toxic materials because they may be toxic if not used in accordance with requirements listed in the Code of Federal Regulations (CFR). Large concentrations of sanitizer in excess of the CFR requirements can be harmful because residues of the materials remain. The CFR reference that is provided lists concentrations of sanitizers that are considered safe.
|
08/03/2015 | Risk Factor | |
Chlorine sanitizer concentration in the mechanical dishmachine checked for proper concentration using the provided test strips (50 - 100 ppm).
- Food Storage Containers, Identified with Common Name of Food (corrected on site) (repeated violation)
Observation: Several dry ingredient containers along the cook-line observed not properly labeled.
Correction: Except for containers holding food that can be readily and unmistakably recognized such as dry pasta, working containers holding food or food ingredients that are removed from their original packages for use in the food establishment, such as cooking oils, flour, herbs, potato flakes, salt, spices, and sugar shall be identified with the common name of the food. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient, when the consumer has specifically requested that it not be used, may result in severe medical consequences. The mistaken use of food from unlabeled containers could result in chemical poisoning.
- Wiping Cloths, Use Limitation (corrected on site)
Observation: Cloths in-use for wiping counters and other equipment surfaces are not held between uses in a chemical sanitizer solution of proper concentration.
Correction: Cloths in-use for wiping counters and other equipment surfaces shall be: (1) Held between uses in a chemical sanitizer solution at a concentration specified under section 4-501.114
- Food Storage/Preventing Contamination from the Premises (corrected on site)
Observation: Container of uncooked broccoli observed stored on the floor in the food preparation area.
Correction: Food shall be protected from contamination by storing the food: (1) In a clean, dry location
- Time/Temperature Control for Safety Food, Cold Holding, Eggs (corrected on site) (repeated violation)
Observation: Container of raw shell eggs observed stored out at room temperature along the cook-line. Product was placed under refrigeration by the person in charge.
Correction: Eggs that have not been treated to destroy all viable Salmonellae shall be stored in refrigerated equipment that maintains an ambient air temperature of 7ºC (45ºF) or less.
- Nonfood-Contact Surfaces/Nonabsorbent (corrected on site)
Observation: The cloth observed used under the small cutting board at the preparation unit is not smooth, easily cleanable, and nonabsorbent.
Correction: Nonfood-contact surfaces of equipment that are exposed to splash, spillage, or other food soiling or that requires frequent cleaning shall be constructed of a corrosion-resistant, nonabsorbent, and smooth material. Nonfood-contact surfaces of equipment routinely exposed to splash or food debris are required to be constructed of nonabsorbent materials to facilitate cleaning. Equipment that is easily cleaned minimizes the presence of pathogenic organisms, moisture, and debris and deters the attraction of rodents and insects.
- Cutting Surfaces
Observation: The small cutting board at the cook-line was observed scratched, scoured, and in need of replacement.
Correction: Surfaces such as cutting blocks and boards that are subject to scratching and scoring shall be resurfaced if they can no longer be effectively cleaned and sanitized, or discarded if they are not capable of being resurfaced. Cutting surfaces such as cutting boards and blocks that become scratched and scored may be difficult to clean and sanitize. As a result, pathogenic microorganisms transmissible through food may build up or accumulate. These microorganisms may be transferred to foods that are prepared on such surfaces.
- Equipment, Food-Contact Surfaces, and Utensils (corrected on site) (repeated violation)
Observation: The metal food bowls and knife along the cook-line preparation unit were observed in need of cleaning and sanitizing.
Correction: Equipment food-contact surfaces and utensils shall be clean to sight and touch. The objective of cleaning focuses on the need to remove organic matter from food-contact surfaces so that sanitization can occur.
- Hand Drying Provision (corrected on site)
Observation: Disposable paper towels were observed not provided at the kitchen handsink.
Correction: Each handwashing sink or group of adjacent handwashing sinks shall be provided with: (A) Individual, disposable towels
- Physical Facilities/Repairing (repeated violation)
Observation: Several floor tiles and areas of coving in the facility observed damaged.
Correction: Physical facilities shall be maintained in good repair. Poor repair and maintenance compromises the functionality of the physical facilities. This requirement is intended to ensure that the physical facilities are properly maintained in order serve their intended purpose.
- Controlling Pests (repeated violation)
Observation: Live roach observed in the kitchen near the single door preparation unit.
Correction: The presence of insects, rodents, and other pests shall be controlled to minimize their presence on the premises by eliminating harborage conditions. Insects and other pests are capable of transmitting disease to man by contaminating food and food-contact surfaces. Effective measures must be taken to control their presence in food establishments.
- Cleaning, Frequency and Restrictions (repeated violation)
Observation: Floor/wall surface throughout the kitchen and underneath equipment observed in need of cleaning.
Correction: Physical facilities shall be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
|
04/07/2015 | Routine | |
- Packaged and Unpackaged Food-Separation, Packaging, and Segregation/Preventing Food and Ingredient Contamination (corrected on site)
Observation: Raw eggs stored on top of vegetables.
Correction: Food shall be protected from cross contamination by separating raw animal foods during storage, preparation, holding, and display from: (a) Raw ready-to-eat food including other raw animal food such as fish for sushi or molluscan shellfish, or other raw ready-to-eat food such as fruits and vegetables, and (b) Cooked ready-to-eat food.
- Time/Temperature Control for Safety Food, Cold Holding (corrected on site) (repeated violation)
Observation: Shrimps at 46 F.
Correction: Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under section 3-501.19, and except as specified under paragraph (B) of this section, time/temperature control for safety food shall be maintained at 5ºC (41ºF) or less. Bacterial growth and/or toxin production can occur if time/temperature control for safety food remains in the temperature "Danger Zone" of 5ºC to 57ºC (41ºF to 135ºF) too long. Up to a point, the rate of growth increases with an increase in temperature within this zone. Beyond the upper limit of the optimal temperature range for a particular organism, the rate of growth decreases. Operations requiring heating or cooling of food should be performed as rapidly as possible to avoid the possibility of bacterial growth.
|
12/05/2014 | Risk Factor | |
Observed live and dead roaches in the kitchen. Establishment was serviced today for pests.
Observed drain from bar three compartment sink not draining properly.
Do not accept potentially hazardous foods at improper temperatures (above 41 F).
- Critical: Temperature/Specifications for Receiving
Observation: Refrigerated rice noodles and bean sprouts received at a temperature above 41ºF. Arrived just after foods had been delivered and observed food at 76 F. Called distributor of rice noodles and manager said noodles were cooked at 11:30 AM. Advised CFM to ice down food for rapid cooling.
Correction: Refrigerated, time/temperature control for safety foods shall be at a temperature of 5ºC (41ºF) or below when received. If a temperature other than 5ºC (41ºF) for a time/temperature control for safety food is specified in law governing its distribution, such as laws governing milk and molluscan shellfish, the food may be received at the specified temperature.
- Equipment, Food-Contact Surfaces, and Utensils (corrected on site) (repeated violation)
Observation: Observed various utensils and multiuse items stored as clean were not clean to sight and touch. Items were returned to dish wash area for cleaning.
Correction: Equipment food-contact surfaces and utensils shall be clean to sight and touch. The objective of cleaning focuses on the need to remove organic matter from food-contact surfaces so that sanitization can occur.
- Cleaning of Plumbing Fixtures (repeated violation)
Observation: Observed handwashing sinks are not clean and/or maintained.
Correction: Plumbing fixtures such as handwashing sinks, toilets, and urinals shall be cleaned as often as necessary to keep them clean and maintained and used as specified under section 5-205.11. Handwashing facilities are critical to food protection and must be maintained in operating order at all times so they will be used.
|
08/11/2014 | Risk Factor | |
Cleaning and organizational improvements have been made. An invoice from the pest control company was provided. According to the manager the pest company is scheduled to return again on or around June 2, 2014.
- Controlling Pests (repeated violation)
Observation: Some live pests observed in the kitchen.
Correction: The presence of insects, rodents, and other pests shall be controlled to minimize their presence on the premises by eliminating harborage conditions. Insects and other pests are capable of transmitting disease to man by contaminating food and food-contact surfaces. Effective measures must be taken to control their presence in food establishments.
|
05/28/2014 | Follow-up | |
A recheck will be conducted. Chlorine sanitizer in the dish-machine checked for proper concentration using the provided test strips.
- Eating, Drinking, or Using Tobacco/Food Contamination Prevention (corrected on site) (repeated violation)
Observation: An employee was eating, drinking, and/or using tobacco in an area where contamination of exposed food or clean equipment may occur (employee's plate of rice on the cook-line).
Correction: An employee shall eat, drink, or use any form of tobacco only in designated areas where the contamination of exposed food
- Food Storage Containers, Identified with Common Name of Food
Observation: Containers of food product/dry goods throughout the kitchen observed not properly labeled.
Correction: Except for containers holding food that can be readily and unmistakably recognized such as dry pasta, working containers holding food or food ingredients that are removed from their original packages for use in the food establishment, such as cooking oils, flour, herbs, potato flakes, salt, spices, and sugar shall be identified with the common name of the food. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient, when the consumer has specifically requested that it not be used, may result in severe medical consequences. The mistaken use of food from unlabeled containers could result in chemical poisoning.
- Critical: Time/Temperature Control for Safety Food, Cold Holding (corrected on site) (repeated violation)
Observation: Container of rice noodles observed on the cook-line at room temperature (product was placed under refrigeration by the person in charge).
Correction: Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under section 3-501.19, and except as specified under paragraph (B) of this section, time/temperature control for safety food shall be maintained at 5ºC (41ºF) or less. Bacterial growth and/or toxin production can occur if time/temperature control for safety food remains in the temperature "Danger Zone" of 5ºC to 57ºC (41ºF to 135ºF) too long. Up to a point, the rate of growth increases with an increase in temperature within this zone. Beyond the upper limit of the optimal temperature range for a particular organism, the rate of growth decreases. Operations requiring heating or cooling of food should be performed as rapidly as possible to avoid the possibility of bacterial growth.
- Critical: Time/Temperature Control for Safety Food, Cold Holding, Eggs (corrected on site)
Observation: Raw shell eggs observed stored out at room temperature on the cook-line (product placed back under refrigeration by the person in charge).
Correction: Eggs that have not been treated to destroy all viable Salmonellae shall be stored in refrigerated equipment that maintains an ambient air temperature of 7ºC (45ºF) or less.
- RTE, TCS, Date Marking/On-Premises Preparation (corrected on site)
Observation: Several ready to eat products in the refrigeration unit(s) observed not properly date labeled (ex. rice, curry).
Correction: Except when packaging food using a reduced oxygen packaging method as specified under section 3-502.12, refrigerated, ready-to-eat, time/temperature control for safety food prepared and held in a food establishment for more than 24 hours shall be clearly marked to indicate the date or day by which the food shall be consumed on the premises, sold, or discarded, based on the temperature of 5ºC (41ºF) or less for a maximum of 7 days. The day of preparation shall be counted as Day 1. A date marking system that meets the criteria of this section may include: (1) Using a method approved by the regulatory authority for refrigerated, ready-to-eat time/temperature control for safety food that is frequently rewrapped, such as lunchmeat or a roast, or for which date marking is impractical, such as soft serve mix or milk in a dispensing machine
- Warewashing Machine, Cleaning Frequency
Observation: Exterior surfaces of the dishmachine observed in need of cleaning.
Correction: A warewashing machine
- Equipment, Food-Contact Surfaces, Nonfood-Contact Surfaces, and Utensils/Clean
Observation: All storage shelving throughout the kitchen observed in need of cleaning.
Correction: The food-contact surfaces of cooking equipment and pans shall be kept free of encrusted grease deposits and other soil accumulations. The objective of cleaning focuses on the need to remove organic matter from food-contact surfaces so that sanitization can occur and to remove soil from nonfood contact surfaces so that pathogenic microorganisms will not be allowed to accumulate and insects and rodents will not be attracted.
- Equipment, Food-Contact Surfaces, and Utensils (repeated violation)
Observation: Food preparation tables observed in need of cleaning. Some knives in the storage container observed in need of cleaning.
Correction: Equipment food-contact surfaces and utensils shall be clean to sight and touch. The objective of cleaning focuses on the need to remove organic matter from food-contact surfaces so that sanitization can occur.
- Equipment/Nonfood-Contact Surfaces/Cleaning Frequency
Observation: Interior of the fryer unit observed in need of cleaning (grease build-up).
Correction: Nonfood-contact surfaces of equipment shall be cleaned at a frequency necessary to preclude accumulation of soil residues. The presence of food debris or dirt on nonfood contact surfaces may provide a suitable environment for the growth of microorganisms which employees may inadvertently transfer to food. If these areas are not kept clean, they may also provide harborage for insects, rodents, and other pests.
- Controlling Pests
Observation: Some live pests observed in the kitchen.
Correction: The presence of insects, rodents, and other pests shall be controlled to minimize their presence on the premises by eliminating harborage conditions. Insects and other pests are capable of transmitting disease to man by contaminating food and food-contact surfaces. Effective measures must be taken to control their presence in food establishments.
- Cleaning, Frequency and Restrictions
Observation: Floor/wall surfaces throughout the kitchen in need of cleaning.
Correction: Physical facilities shall be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
- Cleaning of Plumbing Fixtures
Observation: Kitchen handsink and underneath plumbing fixtures observed in need of cleaning.
Correction: Plumbing fixtures such as handwashing sinks, toilets, and urinals shall be cleaned as often as necessary to keep them clean and maintained and used as specified under section 5-205.11. Handwashing facilities are critical to food protection and must be maintained in operating order at all times so they will be used.
|
05/14/2014 | Routine | |
- Equipment, Food-Contact Surfaces, and Utensils (corrected on site) (repeated violation)
Observation: The knives available for use on knife rack magnet are not clean to sight and touch.
Correction: Equipment food-contact surfaces and utensils shall be clean to sight and touch. The objective of cleaning focuses on the need to remove organic matter from food-contact surfaces so that sanitization can occur.
- Hand Drying Provision (corrected on site) (repeated violation)
Observation: No hand towels available at bar hand sink.
Correction: Each handwashing sink shall be provided with hand towels.
|
01/23/2014 | Follow-up | |
- Eating, Drinking, or Using Tobacco/Food Contamination Prevention (corrected on site)
Observation: An employee was eating, drinking, and/or using tobacco in an area where contamination of exposed food or clean equipment may occur.
Correction: An employee shall eat, drink, or use any form of tobacco only in designated areas where the contamination of exposed food
- Critical: Potentially Hazardous Food, Cold Holding (corrected on site)
Observation: Raw chicken observed at 49 F, raw beef observed at 46 F, in Superior 1 door prep unit that was not maintaining an ambient internal temperature of 41 F or less. Potentially hazardous food items removed from unit. Cooked chicken observed on counter at 65 F. Discarded.
Correction: Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under section 3-501.19, and except as specified under paragraph (B) of this section, Potentially Hazardous Food (Time/Temperature Control for Safety Food) shall be maintained at 5ºC (41ºF) or less. Bacterial growth and/or toxin production can occur if potentially hazardous food (time/temperature control for safety food) remains in the temperature "Danger Zone" of 5ºC to 57ºC (41ºF to 135ºF) too long. Up to a point, the rate of growth increases with an increase in temperature within this zone. Beyond the upper limit of the optimal temperature range for a particular organism, the rate of growth decreases. Operations requiring heating or cooling of food should be performed as rapidly as possible to avoid the possibility of bacterial growth.
- Equipment, Food-Contact Surfaces, and Utensils (corrected on site)
Observation: The knives on the knife magnet are not clean to sight and touch.
Correction: Equipment food-contact surfaces and utensils shall be clean to sight and touch. The objective of cleaning focuses on the need to remove organic matter from food-contact surfaces so that sanitization can occur.
- Handwashing Sink/Using/Operation and Maintenance
Observation: The handwashing station at the employee restroom is being used to clean equipment and utensils.
Correction: The handwashing facility identified above is to be used for washing hands only.
- Handwashing Sink/Using/Operation and Maintenance (repeated violation)
Observation: The handwashing sink located for employee restroom is not maintained so that it is accessible at all times for employee use. Hand sink observed blocked by cases of cooking oil and 5 gallon buckets.
Correction: A handwashing sink shall be maintained so that it is accessible at all times for employee use. Facilities must be maintained in a condition that promotes handwashing and restricted for that use. Convenient accessibility of a handwashing facility encourages timely handwashing which provides a break in the chain of contamination from the hands of food employees to food or food-contact surfaces.
- Hand Drying Provision (corrected on site)
Observation: Each handwashing sink is not provided with individual, disposable towels
Correction: a continuous towel system that supplies the user with a clean towel
- Handwashing Signage
Observation: A sign or poster that notifies food employees to wash their hands is not provided at all handwashing lavatories used by food employees and/or is not clearly visible to food employees. No visible hand wash sign at kitchen hand sink.
Correction: A sign or poster that notifies food employees to wash their hands shall be provided at all handwashing sinks used by food employees and shall be clearly visible to food employees. A sign or poster is required to remind food employees to wash their hands.
- Poisonous or Toxic Materials/Common Name/Working Containers
Observation: Working containers used for storing poisonous or toxic materials are not clearly and/or individually identified with the common name of the material.
Correction: Working containers used for storing poisonous or toxic materials such as cleaners and sanitizers taken from bulk supplies shall be clearly and individually identified with the common name of the material. It is common practice in food establishments to purchase many poisonous or toxic materials including cleaners and sanitizers in bulk containers. Working containers are frequently used to convey these materials to areas where they will be used, resulting in working containers being stored in different locations in the establishment. Identification of these containers with the common name of the material helps prevent the dangerous misuse of the contents.
|
12/17/2013 | Risk Factor | |
- Critical: Potentially Hazardous Food, Cold Holding (corrected on site)
Observation: Garlic-in-mixture (46-53F) and rehydrated rice noodles (70F) were observed at improper cold holding temperature.
Correction: Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under section 3-501.19, and except as specified under paragraph (B) of this section, Potentially Hazardous Food (Time/Temperature Control for Safety Food) shall be maintained at 5ºC (41ºF) or less. Bacterial growth and/or toxin production can occur if potentially hazardous food (time/temperature control for safety food) remains in the temperature "Danger Zone" of 5ºC to 57ºC (41ºF to 135ºF) too long. Up to a point, the rate of growth increases with an increase in temperature within this zone. Beyond the upper limit of the optimal temperature range for a particular organism, the rate of growth decreases. Operations requiring heating or cooling of food should be performed as rapidly as possible to avoid the possibility of bacterial growth.
- Critical: RTE, PHF(TCS), Date Marking/On-Premises Preparation (repeated violation)
Observation: Several curry sauces prepared and held in the food establishment for more than 24 hours is not clearly marked to indicate the date or day by which the food shall be consumed on the premises, sold, or discarded.
Correction: Except when packaging food using a reduced oxygen packaging method as specified under section 3-502.12, refrigerated, ready-to-eat, potentially hazardous food (time/temperature control for safety food) prepared and held in a food establishment for more than 24 hours shall be clearly marked to indicate the date or day by which the food shall be consumed on the premises, sold, or discarded, based on the temperature of 5ºC (41ºF) or less for a maximum of 7 days. The day of preparation shall be counted as Day 1. A date marking system that meets the criteria of this section may include: (1) Using a method approved by the regulatory authority for refrigerated, ready-to-eat potentially hazardous food (time/temperature control for safety food) that is frequently rewrapped, such as lunchmeat or a roast, or for which date marking is impractical, such as soft serve mix or milk in a dispensing machine
- Handwashing Sink/Using/Operation and Maintenance
Observation: The handwashing sink located for the employee restroom was blocked.
Correction: A handwashing sink shall be maintained so that it is accessible at all times for employee use. Facilities must be maintained in a condition that promotes handwashing and restricted for that use. Convenient accessibility of a handwashing facility encourages timely handwashing which provides a break in the chain of contamination from the hands of food employees to food or food-contact surfaces.
- Critical: Poisonous or Toxic Materials/Conditions of Use (corrected on site)
Observation: RAID - ANt & Roach" spray is not used according to law, code, manufacturer's use directions, conditions of certification, or conditions by this regulatory authority.
Correction: Poisonous or toxic materials shall be used according to: (1) Law and this Code, (2) Manufacturer's use directions included in labeling, and, for a pesticide, manufacturer's label instructions that state that use is allowed in a food establishment, (3) The conditions of certification, if certification is required, for use of the pest control materials, and (4) Additional conditions that may be established by the regulatory authority. Failure to properly use poisonous or toxic materials can be dangerous. Many poisonous or toxic materials have general use directions on their label. Failure to follow the stated instructions could result in injury to employees and consumers through direct contact or the contamination of food.
|
08/06/2013 | Risk Factor | |
| No violation noted during this evaluation. | 05/03/2013 | Follow-up | |
- Critical: Temperature/Specifications for Receiving
Observation: Upon receipt, Five Star Rice Noodles were not free of evidence of previous temperature abuse, found in the facility at 70ºF [Do not accept this product unless it is 41ºF or below.]
Correction: Upon receipt, potentially hazardous food (time/temperature control for safety food) shall be free of evidence of previous temperature abuse. Potentially hazardous food (time/temperature control for safety food) shall be at a temperature of 5ºC (41ºF) or below when received. If a temperature other than 5ºC (41ºF) for a potentially hazardous food (time/temperature control for safety food) is specified in law governing its distribution, such as laws governing milk and molluscan shellfish, the food may be received at the specified temperature.
- Critical: Package Integrity (corrected on site)
Observation: A couple dented cans were not in good condition.
Correction: Food packages shall be in good condition and protect the integrity of the contents so that food is not exposed to adulteration or potential contaminants.
- In-Use Utensils, Between-Use Storage
Observation: Food preparation and dispensing utensils are improperly stored [cups found in the rice, sugar bins
Correction: scoop handles found laying in the bar ice and in the flour bins.]
- Critical: Cooling, Cooked Food (corrected on site)
Observation: Rice in the upright refrigerator was not cooling properly in a deep container at 64ºF from this morning.
Correction: Cooked potentially hazardous food (time/temperature control for safety food) shall be cooled: (1) Within 2 hours from 57ºC (135ºF) to 21ºC (70ºF)
- Critical: RTE, PHF(TCS), Date Marking/On-Premises Preparation (repeated violation)
Observation: Prepared curry sauces prepared and held in the food establishment for more than 24 hours are not clearly marked to indicate the date or day by which the food shall be consumed on the premises, sold, or discarded.
Correction: Except when packaging food using a reduced oxygen packaging method as specified under section 3-502.12, refrigerated, ready-to-eat, potentially hazardous food (time/temperature control for safety food) prepared and held in a food establishment for more than 24 hours shall be clearly marked to indicate the date or day by which the food shall be consumed on the premises, sold, or discarded, based on the temperature of 5ºC (41ºF) or less for a maximum of 7 days. The day of preparation shall be counted as Day 1. A date marking system that meets the criteria of this section may include: (1) Using a method approved by the regulatory authority for refrigerated, ready-to-eat potentially hazardous food (time/temperature control for safety food) that is frequently rewrapped, such as lunchmeat or a roast, or for which date marking is impractical, such as soft serve mix or milk in a dispensing machine
- Equipment and Utensils/Durability and Strength
Observation: The "Montgomery Ward" freezer in the closet in the rest-room hallway is not designed and constructed to be durable [a couple of the interior door shelving bars are missing, the light is not shielded or shatter-resistant, and the unit needs defrosting.].
Correction: Equipment and utensils shall be designed and constructed to be durable and to retain their characteristic qualities under normal use conditions. Equipment and utensils must be designed and constructed to be durable and capable of retaining their original characteristics so that such items can continue to fulfill their intended purpose for the duration of their life expectancy and to maintain their easy cleanability. If they can not maintain their original characteristics, they may become difficult to clean, allowing for the harborage of pathogenic microorganisms, insects, and rodents. Equipment and utensils must be designed and constructed so that parts do not break and end up in food as foreign objects or present injury hazards to consumers. A common example of presenting an injury hazard is the tendency for tines of poorly designed single service forks to break during use.
- Equipment/Fixed, Spacing or Sealing
Observation: The mop sink is no longer sealed to its adjoining wall to eliminate spillage or seepage to the wall.
Correction: Equipment that is fixed because it is not easily movable shall be installed so that it is: (1) Spaced to allow access for cleaning along the sides, behind, and above the equipment
- Equipment/Nonfood-Contact Surfaces/Cleaning Frequency
Observation: The nonfood-contact surface of the shelving in the "Montgomery Ward" freezer, the shelving inside the "Ascend" 2-door prep refrigerator, and the men's rest-room ceiling vent cover are not cleaned at a frequency necessary to preclude the accumulation of soil residues.
Correction: Nonfood-contact surfaces of equipment shall be cleaned at a frequency necessary to preclude accumulation of soil residues. The presence of food debris or dirt on nonfood contact surfaces may provide a suitable environment for the growth of microorganisms which employees may inadvertently transfer to food. If these areas are not kept clean, they may also provide harborage for insects, rodents, and other pests.
- Light Bulbs, Protective Shielding
Observation: A set of light bulbs in the kitchen ceiling and the bar ceiling lights are not shielded, coated, or otherwise shatter-resistant.
Correction: Light bulbs shall be shielded, coated, or otherwise shatter-resistant in areas where there is exposed food
- Hand Drying Provision (corrected on site) (repeated violation)
Observation: Each handwashing sink is not provided with individual, disposable towels
Correction: a continuous towel system that supplies the user with a clean towel
- Physical Facilities/Repairing
Observation: The walls and cove base in the employee rest-room and hot water heater area are not maintained in good repair. Some floor tiles and covebase under/behind the cooking equipment in the kitchen are not in good repair.
Correction: Physical facilities shall be maintained in good repair. Poor repair and maintenance compromises the functionality of the physical facilities. This requirement is intended to ensure that the physical facilities are properly maintained in order serve their intended purpose.
- Cleaning, Frequency and Restrictions
Observation: The walls and floors are not cleaned as often as necessary to keep them clean.
Correction: Physical facilities shall be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
- Critical: Food Manager Certificate and Responsibility
Observation: The food establishment is not under the immediate control of a Northern Virginia certified food manager [expired card
Correction: email/fax me copy of new one within 10 days.]
|
04/24/2013 | Routine | |
Superior 1 door prep unit observed not maintaining an ambient temperature of 41oF or less and must not be used for storage of PHF food items until capable of maintaining proper PHF food temperatures.l
- Critical: Potentially Hazardous Food, Cold Holding (corrected on site) (repeated violation)
Observation: Cooked chicken in prep top of Ascend 2 door prep unit observed at 68oF. Raw chicken at 49oF, raw shrimp at 47oF in Superior 1 door prep unit. Items relocated to operational unit.
Correction: Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under section 3-501.19, and except as specified under paragraph (B) of this section, Potentially Hazardous Food (Time/Temperature Control for Safety Food) shall be maintained at 5ºC (41ºF) or less. Bacterial growth and/or toxin production can occur if potentially hazardous food (time/temperature control for safety food) remains in the temperature "Danger Zone" of 5ºC to 57ºC (41ºF to 135ºF) too long. Up to a point, the rate of growth increases with an increase in temperature within this zone. Beyond the upper limit of the optimal temperature range for a particular organism, the rate of growth decreases. Operations requiring heating or cooling of food should be performed as rapidly as possible to avoid the possibility of bacterial growth.
- Critical: RTE, PHF(TCS), Date Marking/On-Premises Preparation (repeated violation)
Observation: Containers of cooked curry sauce, container of dumplings, prepared and held in the food establishment for more than 24 hours is not clearly marked to indicate the date or day by which the food shall be consumed on the premises, sold, or discarded.
Correction: Except when packaging food using a reduced oxygen packaging method as specified under section 3-502.12, refrigerated, ready-to-eat, potentially hazardous food (time/temperature control for safety food) prepared and held in a food establishment for more than 24 hours shall be clearly marked to indicate the date or day by which the food shall be consumed on the premises, sold, or discarded, based on the temperature of 5ºC (41ºF) or less for a maximum of 7 days. The day of preparation shall be counted as Day 1. A date marking system that meets the criteria of this section may include: (1) Using a method approved by the regulatory authority for refrigerated, ready-to-eat potentially hazardous food (time/temperature control for safety food) that is frequently rewrapped, such as lunchmeat or a roast, or for which date marking is impractical, such as soft serve mix or milk in a dispensing machine
- Equipment Food-Contact Surfaces and Utensils/Not Potentially Hazardous/Cleaning Frequency
Observation: Surfaces of the interior of the ice maker were observed with mold build-up and were in need of cleaning.
Correction: Except when dry cleaning methods are used as specified under section 4-603.11, surfaces of utensils and equipment contacting food that is not potentially hazardous (time/temperature control for safety food) shall be cleaned: (1) At any time when contamination may have occurred
- Handwashing Sink/Using/Operation and Maintenance (corrected on site)
Observation: The handwashing sink located for the employee restroom was observed with a mop in basin.
Correction: A handwashing sink shall be maintained so that it is accessible at all times for employee use. Facilities must be maintained in a condition that promotes handwashing and restricted for that use. Convenient accessibility of a handwashing facility encourages timely handwashing which provides a break in the chain of contamination from the hands of food employees to food or food-contact surfaces.
- Hand Drying Provision (corrected on site)
Observation: No hand towels available at bar hand sink.
Correction: Each handwashing sink or group of adjacent handwashing sinks shall be provided with: (A) Individual, disposable towels
- Critical: Poisonous or Toxic Materials/Common Name/Working Containers
Observation: Working containers used for storing poisonous or toxic materials are not clearly and/or individually identified with the common name of the material.
Correction: Working containers used for storing poisonous or toxic materials such as cleaners and sanitizers taken from bulk supplies shall be clearly and individually identified with the common name of the material. It is common practice in food establishments to purchase many poisonous or toxic materials including cleaners and sanitizers in bulk containers. Working containers are frequently used to convey these materials to areas where they will be used, resulting in working containers being stored in different locations in the establishment. Identification of these containers with the common name of the material helps prevent the dangerous misuse of the contents.
|
12/10/2012 | Risk Factor | |
Restaurant representatives - add corrected or new information about Thai Thai Restaurant, 5123 Lee Hwy, Arlington, VA 22207 »