- Cloths - Wiping Cloths - Use Limitation (corrected on site)
Observation: Wiping cloths improperly stored between use.
Correction: Ensure wet wiping cloths are stored in a chemical sanitizer at the proper concentration between use.
- Temperature Measuring Devices (repeated violation)
Observation: There was no temperature measuring device located in the Bev Air Biscuit Cooler.
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Sanitizing Solutions, Testing Devices
Observation: There is no properly working test kit provided in the facility for monitoring the concentration of the chemical sanitizing solutions.
Correction: Obtain a QUAT test kit so that employees can accurately monitor the concentration of the sanitizing solutions and maintain them at a safe and effective level.
|
01/20/2016 | Routine | |
- Temperature Measuring Devices (repeated violation)
Observation: There was no temperature measuring device located in the Drive-Thru Cooler
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Kitchenware and Tableware (corrected on site)
Observation: Cleaned and sanitized utensils not handled, displayed, or dispensed so that the food- or lip-contact surfaces are protected from contamination
Correction: Handle, display, or dispense cleaned and sanitized utensils so the food- or lip-contact surface are protected from contamination.
|
09/09/2015 | Routine | |
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site)
Observation: Raw foods of animal origin stored over ready-to-eat (RTE) food in the refrigeration unit.(Shell eggs stored over onions)
Correction: Separate raw foods of animal origin during storage, preparation, holding, and display from raw RTE food including foods such as fish for sushi or molluscan shellfish, or other raw RTE food such as vegetables, and cooked RTE food.
- Temperature Measuring Devices
Observation: There was no temperature measuring device located in the Drive Through cooler
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Handwashing - Using a Handwashing Lavatory (corrected on site)
Observation: The handwashing facility located at the drive through area is blocked, preventing access by employees for easy handwashing.
Correction: Access to the handwashing facility identified above is to be available during all hours of operation. Remove the trays preventing its use.
|
05/11/2015 | Routine | |
- Critical: Hands and Arms Cleaning Procedure* (corrected on site)
Observation: Improper handwashing procedures observed.
Correction: Ensure all food employees clean their hands and exposed portions of their arms with a cleaning compound in a lavatory by vigorously rubbing together the surfaces of their lathered hands and warms for at least 20 seconds and thoroughly rinsing with clean water.
- Utensils - In-Use - Between-Use Storage (corrected on site)
Observation: Dispensing utensils improperly stored between uses. Unensil observed stored inside product container without handle up
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Cloths - Wiping Cloths - Use Limitation
Observation: Wiping cloths improperly stored between use.(Not in sanitizer)
Correction: Ensure wet wiping cloths are stored in a chemical sanitizer at the proper concentration between use.
|
12/31/2014 | Routine | |
- Cloths - Wiping Cloths - Use Limitation (corrected on site)
Observation: Wiping cloths improperly stored between use.(No sanitizer present)
Correction: Ensure wet wiping cloths are stored in a chemical sanitizer at the proper concentration between use.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site)
Observation: Cut Tomato and shredded cheese cold holding at improper temperatures
Correction: Relocate food to a refrigeration unit that is capable of maintaining food storage at 41°F or below.
- Critical: Toxics - Identifying Toxic Containers* (corrected on site)
Observation: Chemical spray bottle observed without a label. (Garden Sprayer)
Correction: Label spray bottles with contents or discard.
|
09/11/2014 | Routine | |
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site)
Observation: Raw foods of animal origin stored over ready-to-eat (RTE) food in the refrigeration unit. (Shell eggs stored over RTE Ham)
Correction: Separate raw foods of animal origin during storage, preparation, holding, and display from raw RTE food including foods such as fish for sushi or molluscan shellfish, or other raw RTE food such as vegetables, and cooked RTE food.
- Temperature Measuring Devices
Observation: There was no temperature measuring device located in the Beverage Air Upright Cooler
Correction: Provide a temperature measuring device in all hot or cold holding equipment used to store potentially hazardous foods so that employees can routinely monitor the ambient air temperature.
- Sanitizing Solutions, Testing Devices (corrected on site)
Observation: There is no properly working test kit provided in the facility for monitoring the concentration of the chemical sanitizing solutions.
Correction: Obtain a Quats test kit so that employees can accurately monitor the concentration of the sanitizing solutions and maintain them at a safe and effective level.
- Warewashing Equipment, Determining Chemical Sanitizer Concentration (corrected on site)
Observation: A sanitizer test kit is not being used to ensure the chemical sanitizing solution(s) are at the proper concentration. QA sanitizer concentration observed in excess of 400ppm.
Correction: Use a Quats chemical test kit to ensure the sanitizing solution is maintained at the proper solution.
|
05/12/2014 | Routine | |
- Utensils - In-Use - Between-Use Storage (corrected on site) (repeated violation)
Observation: Dispensing utensils improperly stored between uses.(Ice Scoop stored in ice without handle up)
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Handwashing Lavatory, Water Temperature, and Flow
Observation: Water from the handwashing sink at rear prep area was measured at a temperature less than 100°F.
Correction: Make necessary adjustments to valves and lines serving the handsink to provide water of at least 100°F to allow more effective removal of fatty soils encountered in kitchens.
|
01/08/2014 | Routine | |
Discussed hand washing with Person In Charge and glove use.
- Critical: Hands - When to Wash* (corrected on site)
Observation: A food employee failed to wash his between single use glove changes between tasks.
Correction: Instruct food employees to clean their hands and exposed portions of their arms immediately before engaging in food preparation including working with exposed food, clean equipment and utensils, and unwrapped single-service and single-use articles and during food preparation, as often as necessary to remove soil and contamination and to prevent cross contamination when changing task.
- Hand Sanitizers (corrected on site)
Observation: Improper use of a hand sanitizer or chemical hand sanitizing solution observed. (applying a hand sanitizer to unwashed hands)
Correction: Ensure hand sanitizers and chemical hand sanitizing solutions are approved for use by the FDA , have active antimicrobial ingredients that are approved by FDA and are safe for application to human skin as an antiseptic handwash, have components that are exempted from the requirement of being listed in federal food additive regulations, or comply with and be listed in 21 CFR 178 or 21 CFR 182, and be applied only to hands that are cleaned as specified under 12 VAC 5-421-140.
- Cloths - Wiping Cloths - Use Limitation (corrected on site) (repeated violation)
Observation: Wiping cloths improperly stored between use.
Correction: Ensure wet wiping cloths are stored in a chemical sanitizer at the proper concentration between use.
- Critical: Handwashing Lavatory* (corrected on site)
Observation: There is no handwash lavatory at main food prep area has no running water, preventing routine handwashing by food workers.
Correction: Install an additional handwash lavatory at food prep area to allow convenient use by food workers. Prior to installing additional plumbing fixtures the permit holder must apply and gain approval through the necessary regulatory agencies.
- Physical Facilities - Cleaning Frequency and Restrictions
Observation: Walk in Cooler floor noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
|
07/31/2013 | Routine | |
Discussed employee health with PIC
- Critical: Demonstration of Knowledge* (corrected on site)
Observation: The person in charge failed to describe the symptoms associated with diseases that are transmissible through food.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Employee Health* (corrected on site)
Observation: Employees or applicants are not aware of the reporting procedures concerning information about their health and activities as they relate to diseases that are transmissible through food, including the date of onset of jaundice or of an illness due to Salmonella Typhi, Shigella spp., Escherichia coli O157:H7, Hepatitis A virus or Norovirus
Correction: Have the license holder require employees or applicants report to the person in charge any information about their health and activities if they are diagnosed with or had a past illness from Salmonella Typhi, Shigella spp., Escherichia coli O157:H7, Hepatitis A virus or Norovirus
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site)
Observation: Front ice bin is being left uncovered when not in use.
Correction: Protect food from cross contamination by storing food in packages, covered containers, or wrappings.
- Utensils - In-Use - Between-Use Storage (corrected on site)
Observation: Dispensing utensils improperly stored between uses.( Ice scoop store in ice without handle up)
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Cloths - Wiping Cloths - Use Limitation (repeated violation)
Observation: Wiping cloths improperly stored between use.
Correction: Ensure wet wiping cloths are stored in a chemical sanitizer at the proper concentration between use.
- Sanitizing Solutions, Testing Devices
Observation: There is no properly working test kit provided in the facility for monitoring the concentration of the chemical sanitizing solutions.
Correction: Obtain a quats test kit so that employees can accurately monitor the concentration of the sanitizing solutions and maintain them at a safe and effective level.
- Warewashing Equipment, Determining Chemical Sanitizer Concentration
Observation: A sanitizer test kit is not being used to ensure the chemical sanitizing solution(s) are at the proper concentration.
Correction: Use a Quats chemical test kit to ensure the sanitizing solution is maintained at the proper solution.
- Equipment and Utensils, Air-Drying Required
Observation: Storage containers were found stacked while wet after cleaning and chemical sanitization.
Correction: Items must be allowed to drain and air-dry before being stacked or stored to allow evaporation of chemical sanitizer and moisture that may encourage microbial growth.
- Handwashing - Using a Handwashing Lavatory - No Other Purpose (repeated violation)
Observation: The handwash station at the rear of the kitchen is being used for purposes other than washing hands.(Dirty utensils stored in hand sink)
Correction: The handwash facility identified above is to be used for washing hands only
- Physical Facilities in Good Repair (repeated violation)
Observation: The handsink in the rear of the kitchen is not working and is not maintained in good repair
Correction: Maintain physical facilities in good repair. Poor repair and maintenance compromises the functionality of the physical facilities.
|
01/27/2013 | Routine | |
Restaurant representatives - add corrected or new information about Mcdonald's Of Lebanon, 1158 East Main Street, Lebanon, VA 24266 »