- Critical: Good Repair and Calibration
- Items:
- Food thermometer(s)
- Problems:
- Not calibrated
- Corrections:
- Calibrate in accordance with manufacturer specifications.
- Comment:
- Observed inaccurate metal stem thermometer. It was calibrated in my presence. Violation corrected.
- General violation description:
- 4-502.11 - (A) UTENSILS shall be maintained in a state of repair or condition that complies with the requirements specified under Parts 4-1 and 4-2 or shall be discarded. (B) FOOD TEMPERATURE MEASURING DEVICES shall be calibrated in accordance with manufacturer's specifications as necessary to ensure their accuracy. (Pf) (C) Ambient air temperature, water pressure, and water TEMPERATURE MEAURING DEVICES shall be maintained in good repair and be accurate within the intended range of use.
- Critical: Hand Drying Provision
- Items:
- Sanitary hand drying provisions
- Problems:
- Not provided
- Corrections:
- Provide.
- Comment:
- Observed no paper towels for the rear kitchen handsink. Provide paper towels.
- General violation description:
- 6-301.12 - Each HANDWASHING SINK or group of adjacent HANDWASHING SINKS shall be provided with: (A) Individual, disposable towels
- Critical: Handwashing Cleanser, Availabi
- Items:
- Soap
- Problems:
- Not provided
- Corrections:
- Provide.
- Comment:
- Observed no soap for rear kitchen handsink. Provide soap.
- General violation description:
- 6-301.11 - Each HANDWASHING SINK or group of 2 adjacent HANDWASHING SINKS shall be provided with a supply of hand cleaning liquid, powder, or bar soap.(Pf)
- Critical: Sanitizing Solutions, Testing
- Items:
- Sanitizer test kit
- Problems:
- Not provided
- Corrections:
- Provide.
- Comment:
- Observed no quaternary ammonia test kit for the three compartment sink. Provide test kit and use 200 ppm of sanitizer.
- General violation description:
- 4-302.14 - A test kit or other device that accurately measures the concentration in MG/L of SANITIZING solutions shall be provided. (Pf)
- Cleaning, Frequency and Restri
- Items:
- Physical facilities/structures
- Problems:
- Soiled
- Corrections:
- Keep clean.
- Comment:
- Observed food on floor under fryers. Clean the floor.
- General violation description:
- 6-501.12 - (A) PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean. (B) Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
- Cooking and Baking Equipment
- Items:
- Baking and cooking equipment
- Problems:
- Not cleaned
- Corrections:
- Clean as required above.
- Comment:
- Observed dried food debris in microwave oven. Clean to sight and touch daily.
- General violation description:
- 4-602.12 - (A) The FOOD-CONTACT SURFACES of cooking and baking EQUIPMENT shall be cleaned at least every 24 hours. This section does not apply to hot oil cooking and filtering EQUIPMENT if it is cleaned as specified in Subparagraph 4-602.11(D)(6). (B) The cavities and door seals of microwave ovens shall be cleaned at least every 24 hours by using the manufacturer's recommended cleaning procedure.
- Handwashing Signage
- Items:
- Handwashing signage
- Problems:
- Not provided
- Corrections:
- Provide.
- Comment:
- Observed no handwashing signs for kitchen handsinks. Provide handwashing signs.
- General violation description:
- 6-301.14 - A sign or poster that notifies FOOD EMPLOYEES to wash their hands shall be provided at all HANDWASHING SINKS used by FOOD EMPLOYEES and shall be clearly visible to FOOD EMPLOYEES.
- Outer Openings, Protected
- Items:
- Outer opening(s)
- Problems:
- Not sealed to prevent pest entry
- Corrections:
- Seal to prevent pest entry.
- Comment:
- Observed front door propped open. It was closed in my presence. Violation corrected.
- General violation description:
- 6-202.15 - (A) Except as specified in ## (B), (C), and (E) and under # (D) of this section, outer openings of a FOOD ESTABLISHMENT shall be protected against the entry of insects and rodents by: (1) Filling or closing holes and other gaps along floors, walls, and ceilings
- System Maintained in Good Repa
- Items:
- Plumbing system
- Problems:
- Not maintained
- Corrections:
- Maintain in good repair
- Comment:
- Observed hot and cold water shut off at food prep handsink. Repair or replace this handsink.
- General violation description:
- 5-205.15 - A PLUMBING SYSTEM shall be: (A) Repaired according to LAW
- Temperature Measuring Devices
- Items:
- Thermometer(s)
- Problems:
- Not provided
- Corrections:
- Provide.
- Comment:
- Observed no thermometer in the pizza prep cooler. A thermometer was provided. Violation corrected.
- General violation description:
- 4-204.112 - (A) In a mechanically refrigerated or hot FOOD storage unit, the sensor of a TEMPERATURE MEASURING DEVICE shall be located to measure the air temperature or a simulated product temperature in the warmest part of a mechanically refrigerated unit and in the coolest part of a hot FOOD storage unit. (B) Except as specified in # (C) of this section, cold or hot holding EQUIPMENT used for POTENTIALLY HAZARDOUS FOOD (TIME/TEMPERATURE CONTROL FOR SAFETY FOOD) shall be designed to include and shall be equipped with at least one integral or permanently affixed TEMPERATURE MEASURING DEVICE that is located to allow easy viewing of the device's temperature display. (C) Paragraph (B) of this section does not apply to EQUIPMENT for which the placement of a TEMPERATURE MEASURNG DEVICE is not a practical means for measuring the ambient air surrounding the FOOD because of the design, type, and use of the EQUIPMENT, such as calrod units, heat lamps, cold plates, bainmaries, steam tables, insulated FOOD transport containers, and salad bars. (D) TEMPERATURE MEASURING DEVICES shall be designed to be easily readable. (E) FOOD TEMPERATURE MEASURING DEVICES and water TEMPERATURE MEASURING DEVICES on WAREWASHING machines shall have a numerical scale, printed record, or digital readout in increments no greater than 1°C or 2°F in the intended range of use.(Pf)
- Ventilation Hood Systems, Drip
- Items:
- Exhaust ventilation hood system(s)
- Problems:
- Designed to allow grease or condensation from draining/dripping onto
- Corrections:
- Repair/replace to prevent grease accumulation/dripping/draining.
- Comment:
- Observed gap in exhaust hood above the pizza oven. Install spacer bar.
- General violation description:
- 4-204.11 - Exhaust ventilation hood systems in FOOD preparation and WAREWASHING areas including components such as hoods, fans, guards, and ducting shall be designed to prevent grease or condensation from draining or dripping onto FOOD, EQUIPMENT, UTENSILS, LINENS, and SINGLE-SERVICE and SINGLE-USE ARTICLES.
|
09/11/2014 | Routine |
- Critical: Handwashing Cleanser, Availabi
- Items:
- Soap
- Problems:
- Not provided
- Corrections:
- Provide.
- Comment:
- Observed no soap for the restroom handsink. Soap was provided in my presence. Violation corrected.
- General violation description:
- 6-301.11 - Each HANDWASHING SINK or group of 2 adjacent HANDWASHING SINKS shall be provided with a supply of hand cleaning liquid, powder, or bar soap.(Pf)
- Critical: Sanitizing Solutions, Testing
- Items:
- Sanitizer test kit
- Problems:
- Not provided
- Corrections:
- Provide.
- Comment:
- Observed no quaternary ammonia test kit for checking the sanitizer in the 3 compartment sink. Provide a quaternary ammonia test kit.
- General violation description:
- 4-302.14 - A test kit or other device that accurately measures the concentration in MG/L of SANITIZING solutions shall be provided. (Pf)
- Critical: Using a Handwashing Sink
- Items:
- Handwashing sink(s)
- Problems:
- Not easily accessible
- Corrections:
- Make easily accessible.
- Comment:
- Observed center handsink for the cookline blocked by a food prep table. Handsinks must be kept accessible. Remove table from in front of this handsink.
- General violation description:
- 5-205.11 - (A) A HANDWASHING SINK shall be maintained so that it is accessible at all times for EMPLOYEE use. (Pf) (B) A HANDWASHING SINK may not be used for purposes other than handwashing. (Pf) (C) An automatic handwashing facility shall be used in accordance with manufacturer's instructions. (Pf)
- Cleaning, Frequency and Restri
- Items:
- Physical facilities/structures
- Problems:
- Soiled
- Corrections:
- Keep clean.
- Comment:
- Observed moldy drain lines in cupboard under the pop dispenser in dining room. Clean the drain lines to sight and touch on a weekly basis.
- General violation description:
- 6-501.12 - (A) PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean. (B) Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
- Good Repair and Proper Adjustm
- Items:
- Equipment
- Problems:
- In poor repair
- Corrections:
- Repair/replace.
- Comment:
- Observed heavy ice build-up on floor of the walk-in freezer. Defrost this freezer to remove the ice.
- General violation description:
- 4-501.11 - (A) EQUIPMENT shall be maintained in a state of repair and condition that meets the requirements specified under Parts 4-1 and 4-2. (B) EQUIPMENT components such as doors, seals, hinges, fasteners, and kick plates shall be kept intact, tight, and adjusted in accordance with manufacturer's specifications. (C) Cutting or piercing parts of can openers shall be kept sharp to minimize the creation of metal fragments that can contaminate FOOD when the container is opened.
- Intensity
- Items:
- Lighting intensity
- Problems:
- Less than
- Comment:
- Observed 3 light bulbs burned out above the pizza oven. Replace the burned out light bulbs to provide proper illumination.
- General violation description:
- 6-303.11 - The light intensity shall be: (A) At least 108 lux (10 foot candles) at a distance of 75 cm (30 inches) above the floor, in walk-in refrigeration units and dry FOOD storage areas and in other areas and rooms during periods of cleaning
- Nonfood-Contact Surfaces
- Items:
- Nonfood contact surface(s)
- Problems:
- Soiled
- Corrections:
- Keep clean.
- Comment:
- Observed soiled bottom shelf in the food prep cooller. Non-food contact equipment must be kept clean. Clean to sight and touch as needed.
- General violation description:
- 4-602.13 - NonFOOD-CONTACT SURFACES of EQUIPMENT shall be cleaned at a frequency necessary to preclude accumulation of soil residues.
- Repairing
- Items:
- Physical facilities
- Problems:
- In poor repair
- Corrections:
- Repair/replace.
- Comment:
- Observed missing ceiling tile above the front handsink at cookline. Replace the ceiling tile.
- General violation description:
- 6-501.11 - PHYSICAL FACILITIES shall be maintained in good repair.
|
02/24/2014 | Routine |
Restaurant representatives - add corrected or new information about The Pizza Shack, 27420 Six Mile Rd, Livonia, MI 48152 »