- Critical: Before Use After Cleaning
- Comment:
- Observed 3 compartment sink used correctly. Corrected
- General violation description:
- 4-702.11 - UTENSILS and FOOD-CONTACT SURFACES of EQUIPMENT shall be SANITIZED before use after cleaning.
- Critical: Equipment, Food-Contact Surfac
- Comment:
- Observed prep sink clean. Corrected
- General violation description:
- 4-601.11 - (A) EQUIPMENT FOOD-CONTACT SURFACES and UTENSILS shall be clean to sight and touch. (B) The FOOD-CONTACT SURFACES of cooking EQUIPMENT and pans shall be kept free of encrusted grease deposits and other soil accumulations. N (C) NonFOOD-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris. N
- Critical: Hand Drying Provision
- Comment:
- Observed paper towels at all hand sinks. Correct immediately
- General violation description:
- 6-301.12 - Each HANDWASHING SINK or group of adjacent HANDWASHING SINKS shall be provided with: (A) Individual, disposable towels
- Critical: Packaged and Unpackaged Food -
- Comment:
- Observed no cross contamination in coolers. Corrected
- General violation description:
- 3-302.11 - (A) FOOD shall be protected from cross contamination by: (1) Separating raw animal FOODS during storage, preparation, holding, and display from: (a) Raw READY-TO-EAT FOOD including other raw animal FOOD such as FISH for sushi or MOLLUSCAN SHELLFISH, or other raw READY-TO-EAT FOOD such as vegetables, and (b) Cooked READY-TO-EAT FOOD
- Critical: Person in Charge
- Comment:
- Observed a person in charge at time of inspection. Corrected
- General violation description:
- 2-103.11 - The PERSON IN CHARGE shall ensure that: (A) FOOD ESTABLISHMENT operations are not conducted in a private home or in a room used as living or sleeping quarters as specified under # 6-202.111
- Critical: Where to Wash
- Comment:
- Observed hand sinks used to was hands. Corrected
- General violation description:
- 2-301.15 - FOOD EMPLOYEES shall clean their hands in a HANDWASHING SINK or APPROVED automatic handwashing facility and may not clean their hands in a sink used for FOOD preparation or WAREWASHING, or in a service sink or a curbed cleaning facility used for the disposal of mop water and similar liquid waste. (Pf)
- Effectiveness
- Comment:
- Observed hats worn when preparing food. Corrected
- General violation description:
- 2-402.11 - (A) Except as provided in # (B) of this section, FOOD EMPLOYEES shall wear hair restraints such as hats, hair coverings or nets, beard restraints, and clothing that covers body hair, that are designed and worn to effectively keep their hair from contacting exposed FOOD
- Food Storage
- Comment:
- Observed all food stored at least 6 inches off the ground. Corrected
- General violation description:
- 3-305.11 - (A) Except as specified in ## (B) and (C) of this section, FOOD shall be protected from contamination by storing the FOOD: (1) In a clean, dry location
|
06/11/2015 | Follow-up |
- Critical: Before Use After Cleaning
- Items:
- Clean utensil(s) and food-contact surface(s)
- Problems:
- Not sanitized
- Corrections:
- Equipment/utensils must be sanitized after cleaning.
- Comment:
- Observed employees not sanitizing utensils after cleaning them. 3 compartment sink not used or set up correctly. Food contact surfaces must be washed, rinsed, sanitized then air dried. Train employees how to set up 3 compartment sink correctly as well as to sanitize all food contact surfaces. Use Quat or chlorine sanitizer. Correct immediately,
- General violation description:
- 4-702.11 - UTENSILS and FOOD-CONTACT SURFACES of EQUIPMENT shall be SANITIZED before use after cleaning.
- Critical: Equipment, Food-Contact Surfac
- Items:
- Food-contact surface(s) Equipment
- Problems:
- With accumulation of debris
- Corrections:
- Keep clean.
- Comment:
- Observed prep sink with lettuce in it with red debris on sides of sink. Completely clean and sanitize sink before putting food in sink. Food contact surfaces must be clean and sanitized. Discard lettuce and clean and sanitize sink before using. Correct immediately,
- General violation description:
- 4-601.11 - (A) EQUIPMENT FOOD-CONTACT SURFACES and UTENSILS shall be clean to sight and touch. (B) The FOOD-CONTACT SURFACES of cooking EQUIPMENT and pans shall be kept free of encrusted grease deposits and other soil accumulations. N (C) NonFOOD-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris. N
- Critical: Hand Drying Provision
- Items:
- Sanitary hand drying provisions disposable, paper towels
- Problems:
- Not provided At hand sink
- Corrections:
- provide
- Comment:
- Observed no paper towels at front counter hand sink. All hand washing sinks must have paper towels at all times. Correct immediately,
- General violation description:
- 6-301.12 - Each HANDWASHING SINK or group of adjacent HANDWASHING SINKS shall be provided with: (A) Individual, disposable towels
- Critical: Packaged and Unpackaged Food -
- Items:
- Raw animal food(s)
- Problems:
- Stored over/next to Ready-to-eat food(s)
- Corrections:
- Store raw animal foods below and away from foods needing little or no further prep.
- Comment:
- Observed raw meat stored on shelf above dough in walk in cooler. Observed raw chicken in a box stored above lettuce and peppers in walk in cooler. Store raw foods below and away from ready to eat foods. Correct immediately,
- General violation description:
- 3-302.11 - (A) FOOD shall be protected from cross contamination by: (1) Separating raw animal FOODS during storage, preparation, holding, and display from: (a) Raw READY-TO-EAT FOOD including other raw animal FOOD such as FISH for sushi or MOLLUSCAN SHELLFISH, or other raw READY-TO-EAT FOOD such as vegetables, and (b) Cooked READY-TO-EAT FOOD
- Critical: Person in Charge
- Items:
- Person-in-charge
- Problems:
- Not ensuring compliance
- Corrections:
- Person-in-charge must ensure compliance with items listed above.
- Comment:
- Observed no one in charge. Employees states that person in charge is not here. A person must be in charge at all hours of operation. Insure that a person in charge is in establishment at all hours of operation. Correct immediately,
- General violation description:
- 2-103.11 - The PERSON IN CHARGE shall ensure that: (A) FOOD ESTABLISHMENT operations are not conducted in a private home or in a room used as living or sleeping quarters as specified under # 6-202.111
- Critical: Potentially Hazardous Food (Ti
- Items:
- Cold food item(s)
- Problems:
- Stored above 41 degrees f
- Corrections:
- Store below 41 degrees F.
- Comment:
- Observed raw chicken, coked beef, cooked lamb and other food in walk in cooler at 49 - 52 degrees in walk in cooler. Cooler at 46 degrees with door ajar. Discard all potentially hazardous food in cooler. Potentially hazardous foods must be held at or below 41 degrees at all times. Observed cut lettuce and beef on top level and in 2 door line prep cooler at 49 degrees. Discard. Cooler at 46 degrees. Correct immediately
- General violation description:
- 3-501.16 - Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under 3-501.19, POTENTIALLY HAZARDOUS FOOD shall be maintained: (A) At 60C (140F) or above, except that roasts cooked to a temperature and for a time specified under 3-401.11(B) or reheated as specified in 3-403.11(E) may be held at a temperature of 54C (1300F)
- Critical: Preventing Contamination from
- Items:
- Ready-to-eat food(s)
- Problems:
- Handled with bare hands
- Corrections:
- Suitable utensils or single-use gloves are to be utilized.
- Comment:
- Observed lemons and other ready to eat foods handled with bare hands. Employees must use gloves, tongs, or deli tissue when handling ready to eat foods. Correct immediately
- General violation description:
- 3-301.11 - (A) FOOD EMPLOYEES shall wash their hands as specified under 2-301.12. (B) Except when washing fruits and vegetables as specified under 3-302.15 or when otherwise APPROVED, FOOD EMPLOYEES may not contact exposed, READY-TO-EAT FOOD with their bare hands and shall use suitable UTENSILS such as deli tissue, spatulas, tongs, SINGLE-USE gloves, or dispensing EQUIPMENT. (C) FOOD EMPLOYEES shall minimize bare hand and arm contact with exposed FOOD that is not in a READY-TO-EAT form. S
- Critical: System Maintained in Good Repa
- Items:
- Plumbing system
- Problems:
- Not repaired according to law
- Corrections:
- Repair according to law.
- Comment:
- Observed vacuum breaker at mop sink with major leak. Fix leak. Plumbing systems must be in good repair and vacuum breakers must be working. Correct immediately
- General violation description:
- 5-205.15 - A PLUMBING SYSTEM shall be: (A) Repaired according to LAW
- Critical: Using a Handwashing Sink
- Items:
- Handwashing sink(s)
- Problems:
- Not accessible
- Corrections:
- Handwashing sinks are to be accessible for use at all times
- Comment:
- Observed hand sink in kitchen not accessible. Hand washing sink must be fully accessible at all times. Keep accessible. Do not store items in front of or in hand sink. .
- General violation description:
- 5-205.11 - (A) A HANDWASHING SINK shall be maintained so that it is accessible at all times for EMPLOYEE use. (Pf) (B) A HANDWASHING SINK may not be used for purposes other than handwashing. (Pf) (C) An automatic handwashing facility shall be used in accordance with manufacturer's instructions. (Pf)
- Critical: Where to Wash
- Items:
- Employee washed/rinsed hands
- Problems:
- In three compartment sink
- Corrections:
- Hands shall be washed in handsink(s) only.
- Comment:
- Hand sink was blacked in kitchen. When asked, employees said they wash hands in 3 compartment sink. Hands must be washed in a hand sink for at least 20 seconds with soap then hands dried with paper towels. Train employees on where and how to wash hands. Correct immediately,
- General violation description:
- 2-301.15 - FOOD EMPLOYEES shall clean their hands in a HANDWASHING SINK or APPROVED automatic handwashing facility and may not clean their hands in a sink used for FOOD preparation or WAREWASHING, or in a service sink or a curbed cleaning facility used for the disposal of mop water and similar liquid waste. (Pf)
- Cleaning, Frequency and Restri
- Items:
- Physical facilities/structures floors
- Problems:
- Not clean
- Corrections:
- Keep clean
- Comment:
- Clean entire mixer attachment and area around mixer. Clean the floors under all equipment. Physical facilities must be clean. Correct immediately
- General violation description:
- 6-501.12 - (A) PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean. (B) Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
- Effectiveness
- Items:
- Hair restraint hat
- Problems:
- Not worn on head/hair
- Corrections:
- Provide hat or hair net.
- Comment:
- Observed two employees preparing food without a hat or hair net. All employees preparing food must wear a hat or hair net. Correct immediately,
- General violation description:
- 2-402.11 - (A) Except as provided in # (B) of this section, FOOD EMPLOYEES shall wear hair restraints such as hats, hair coverings or nets, beard restraints, and clothing that covers body hair, that are designed and worn to effectively keep their hair from contacting exposed FOOD
- Food Storage
- Items:
- Food item(s) in storage
- Problems:
- Stored on floor or less than 6 inches above floor Not covered
- Corrections:
- Store at least 6 inches above the floor.
- Comment:
- Observed pepper box on top of garbage can, observed lettuce container on floor in prep area, and observed many food boxes on ground in dry storage room and walk in cooler. Store all food at least 6 inches off the ground at all times. Correct immediately,
- General violation description:
- 3-305.11 - (A) Except as specified in ## (B) and (C) of this section, FOOD shall be protected from contamination by storing the FOOD: (1) In a clean, dry location
- Wiping Cloths, Use Limitation
- Items:
- Wiping cloth(s) wet
- Problems:
- Stored on Counter
- Corrections:
- Store wiping cloths completely submersed in sanitizer.
- Comment:
- , Observed wet rags stored on counter. No rag bucket set up. Provide rag bucket with sanitizer in it to store in between wet rags in it. Do not store wet rags on counter. Correct immediately
- General violation description:
- 3-304.14 - (A) Cloths in-use for wiping food spills from TABLEWARE and carry-out containers that occur as FOOD is being served shall be: (1) Maintained dry
|
06/01/2015 | Routine |
- Critical: Backflow Prevention
- Comment:
- CORRECTED BY PROVIDING AT LEAST A 1 INCH AIR GAP FOR THE WALK-IN COOLER/FREEZER CONDENSER LINES, THE SANITIZE AND PREP SINK DRAIN LINES AND THE ICE MACHINE DRAIN LINE.
- General violation description:
- 5-402.11 - (A) Except as specified in (B) and (C) of this section, a direct connection may not exist between the SEWAGE system and a drain originating from EQUIPMENT in which FOOD, portable EQUIPMENT, or UTENSILS are placed. (B) If allowed by LAW, a WAREWASHING machine may have a direct connection between its waste outlet and a floor drain when the machine is located within 1.5 m (5 feet) of a trapped floor drain and the machine outlet is connected to the inlet side of a properly vented floor drain trap. (C) If allowed by LAW, a WAREWASHING or culinary sink may have a direct connection.
- Critical: Capacity
- Comment:
- CORRECTED. SPOKE WITH CONTRACTOR AND THE UNIT IS A LOCHINVAR 100G / 199,999 BTU / 193 GPH. PROVIDE PLATE FOR FUTURE INSPECTIONS.
- General violation description:
- 5-103.11 - (A) The water source and system shall be of sufficient capacity to meet the peak water demands of the FOOD ESTABLISHMENT. (B) Hot water generation and distribution systems shall be sufficient to meet the peak hot water demands throughout the FOOD ESTABLISHMENT.
- Critical: Consumption of Animal Foods th
- Comment:
- CORRECTED BY PROVIDING A COPY OF THE FINAL MENU WHICH CONTAINS THE CONSUMER ADVISORY OF "ASK YOUR SERVER...".
- General violation description:
- 3-603.11 - Except as specified in 3-401.11(C) and Subparagraph 3-401.11(D)(3) and under 3-801.11(D), if an animal FOOD such as beef, eggs, FISH, lamb, milk, pork, POULTRY, or shellfish that is raw, undercooked, or not otherwise processed to eliminate pathogens is offered in a READY-TO-EAT form as a deli, menu, vended, or other item
- Critical: Sanitizing Solutions, Testing
- Comment:
- CORRECTED BY PROVIDING A SANITIZER TEST KIT FOR CHLORINE AND ONE FOR QUATERNARY AMMONIUM.
- General violation description:
- 4-302.14 - A test kit or other device that accurately measures the concentration in MG/L of SANITIZING solutions shall be provided. (Pf)
- Critical: System Maintained in Good Repa
- Comment:
- CORRECTED BY PROVIDING DRAIN PLUGS FOR RINSE, SANITIZE AND PREP SINKS. ALSO, MOP SINK FAUCET LEAK WAS REPAIRED.
- General violation description:
- 5-205.15 - A PLUMBING SYSTEM shall be: (A) Repaired according to LAW
- Critical: Temperature Measuring Devices
- Comment:
- CORRECTED BY PROVIDING AMBIENT AIR THERMOMETERS IN ALL COOLERS.
- General violation description:
- 4-204.112 - (A) In a mechanically refrigerated or hot FOOD storage unit, the sensor of a TEMPERATURE MEASURING DEVICE shall be located to measure the air temperature or a simulated product temperature in the warmest part of a mechanically refrigerated unit and in the coolest part of a hot FOOD storage unit. (B) Except as specified in # (C) of this section, cold or hot holding EQUIPMENT used for POTENTIALLY HAZARDOUS FOOD (TIME/TEMPERATURE CONTROL FOR SAFETY FOOD) shall be designed to include and shall be equipped with at least one integral or permanently affixed TEMPERATURE MEASURING DEVICE that is located to allow easy viewing of the device's temperature display. (C) Paragraph (B) of this section does not apply to EQUIPMENT for which the placement of a TEMPERATURE MEASURNG DEVICE is not a practical means for measuring the ambient air surrounding the FOOD because of the design, type, and use of the EQUIPMENT, such as calrod units, heat lamps, cold plates, bainmaries, steam tables, insulated FOOD transport containers, and salad bars. (D) TEMPERATURE MEASURING DEVICES shall be designed to be easily readable. (E) FOOD TEMPERATURE MEASURING DEVICES and water TEMPERATURE MEASURING DEVICES on WAREWASHING machines shall have a numerical scale, printed record, or digital readout in increments no greater than 1°C or 2°F in the intended range of use.(Pf)
- Cleaning, Frequency and Restri
- Comment:
- CORRECTED BY CLEANING THE FLOORS AND EDGES IN THE FACILITY.
- General violation description:
- 6-501.12 - (A) PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean. (B) Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
- Cutting Surfaces
- Comment:
- CORRECTED BY SANDING DOWN THE CUTTING BOARD TO MAKE SMOOTH AND EASILY CLEANABLE.
- General violation description:
- 4-501.12 - Surfaces such as cutting blocks and boards that are subject to scratching and scoring shall be resurfaced if they can no longer be effectively cleaned and SANITIZED, or discarded if they are not capable of being resurfaced.
- Drying Mops
- Comment:
- CORRECTED BY INSTALLING A MOP HANGER OVER THE MOP SINK.
- General violation description:
- 6-501.16 - After use, mops shall be placed in a position that allows them to air-dry without soiling walls, EQUIPMENT, or supplies.
- Equipment, Utensils, Linens, a
- Comment:
- CORRECTED BY STORING THE MIXER ON A STAINLESS STEEL STAND.
- General violation description:
- 4-903.11 - (A) Except as specified in # (D) of this section, cleaned EQUIPMENT and UTENSILS, laundered LINENS, and SINGLE-SERVICE and SINGLE-USE ARTICLES shall be stored: (1) In a clean, dry location
- Floor and Wall Junctures, Cove
- Comment:
- CORRECTED BY INSTALLING VINYL COVE BASE IN THE DRY STORAGE ROOM AND BOTH RESTROOMS.
- General violation description:
- 6-201.13 - (A) In FOOD ESTABLISHMENTS in which cleaning methods other than water flushing are used for cleaning floors, the floor and wall junctures shall be coved and closed to no larger than 1 mm (one thirty-second inch). (B) The floors in FOOD ESTABLISHMENTS in which water flush cleaning methods are used shall be provided with drains and be graded to drain, and the floor and wall junctures shall be coved and SEALED.
- Floors, Walls, and Ceilings
- Comment:
- CORRECTED BY INSTALLING SMOOTH AND EASILY CLEANABLE CEILING TILES IN BOTH RESTROOMS.
- General violation description:
- 6-201.11 - Except as specified under # 6-201.14 and except for antislip floor coverings or applications that may be used for safety reasons, floors, floor coverings, walls, wall coverings, and ceilings shall be designed, constructed, and installed so they are SMOOTH and EASILY CLEANABLE.
- Handwashing Signage
- Comment:
- CORRECTED BY POSTING HANDWASH SIGNS AT ALL HANDWASH SINKS.
- General violation description:
- 6-301.14 - A sign or poster that notifies FOOD EMPLOYEES to wash their hands shall be provided at all HANDWASHING SINKS used by FOOD EMPLOYEES and shall be clearly visible to FOOD EMPLOYEES.
- Nonfood-Contact Surfaces
- Comment:
- CORRECTED BY CLEANING ALL NOTED ITEMS.
- General violation description:
- 4-602.13 - NonFOOD-CONTACT SURFACES of EQUIPMENT shall be cleaned at a frequency necessary to preclude accumulation of soil residues.
- Nonfood-Contact Surfaces
- Comment:
- CORRECTED BY COATING BOTTOM SHELF OF PREP TABLE AND THE BARE WOOD AREAS UNDER SHELVING TO MAKE THEM SMOOTH AND EASILY CLEANABLE.
- General violation description:
- 4-202.16 - NonFOOD-CONTACT SURFACES shall be free of unnecessary ledges, projections, and crevices, and designed and constructed to allow easy cleaning and to facilitate maintenance.
- Toilet Room Receptacle, Covere
- Comment:
- CORRECTED BY PROVIDING A COVERED GARBAGE CAN IN THE WOMEN'S RESTROOM.
- General violation description:
- 5-501.17 - A toilet room used by females shall be provided with a covered receptacle for sanitary napkins.
|
03/30/2015 | Follow-up |
Restaurant representatives - add corrected or new information about Arabian Village Restaurant, 10421 Dix Ave, Dearborn, MI 48120 »